Maintenance; Preventive Maintenance; Schedule; Tips - Life Fitness Weekly Service Manual

3. Maintenance

Preventive Maintenance Schedule
Item
Console Overlays
Bottle Holders / Accessory
Trays
Console Mounting Bolts
Hardware
Frame
Plastic Covers
Lifepulse Sensors
Striding Belt Centered
Emergency Stop Magnet
Motor Cover
Motor Electronic
Compartment
Drive Belt
Leg Levelers
Front and Rear Rollers
Side Step Area
Side Hand Rails
Ergo ™ Front Handlebar
Preventive Maintenance Tips
NOTE: Safety of the equipment can be maintained only if the equipment is examined regularly for damage or wear.
Keep the equipment out of use until defective parts are repaired or replaced. Pay special attention to parts that are
subject to wear, as outlined below.
The following preventive maintenance tips will keep the product operating at peak performance:
• Locate the product in a cool, dry place.
• Clean the display console and all exterior surfaces with an approved or compatible cleaner (see Approved and
Compatible Cleaners) and a microfiber cloth.
• Long fingernails may damage or scratch the surface of the console; use the pad of the finger to press the selection
buttons on the console.
• Check operation of the emergency stop system once a week.
• Inspect and vacuum the area directly surrounding and under the unit regularly.
• Vacuum around the striding belt regularly to keep debris from accumulating.
• Inspect exterior parts regularly for wear, particularly the striding belt, deck and line cord.
• Check to make sure the unit is properly leveled.
• Check the position (centering) of the striding belt.
NOTE: Normal belt operating position is for the belt to be located within the belt travel indicators on the rear roller
guards. Refer to Tracking (Centering) A Striding Belt or contact Customer Support Services for proper alignment
instructions.
Weekly
Clean
Clean
Clean
Clean
Clean / Inspect
Inspect
Clean / Inspect
Clean
Clean
Clean
Clean
Page 7 of 143
Monthly
Inspect
Inspect
Vacuum / Clean
Inspect / Adjust
Inspect
Biannually
Inspect
Inspect
Inspect
Inspect
Inspect
Inspect
Inspect
Inspect
Inspect