Warnings; Pay Attention To These Terms - Raypak 406A Installation And Operation Manual

1. WARNINGS

Pay Attention to These Terms

Indicates the presence of immediate hazards which will cause severe personal injury, death or
DANGER
A
substantial property damage if ignored.
Indicates the presence of hazards or unsafe practices which could cause severe personal injury,
WARNING
A
death or substantial property damage if ignored.
Indicates the presence of hazards or unsafe practices which could cause minor personal injury
CAUTION
A
or product or property damage if ignored.
CAUTION used without the warning alert symbol indicates a potentially hazardous condition
CAUTION
which could cause minor personal injury or product or property damage if ignored.
Indicates special instructions on installation, operation, or maintenance which are important but
NOTE
not related to personal injury hazards.
A DANGER: Failure to install the drafthood on indoor
installation and properly vent the heater to the outdoors
as outlined in the venting section of this manual can
result in unsafe operation of the heater. To avoid the risk
of fire, explosion, or asphyxiation from carbon monoxide,
never operate this heater unless it is properly vented
and has an adequate air supply for proper operation. Be
sure to inspect the vent system for proper installation at
initial start-up, and at least annually thereafter. Refer to
the venting section of this manual for more information
regarding vent system inspections.
A WARNING: To minimize the possibility of improper
operation, serious personal injury, fire, or damage to the
heater:
• Always keep the area around the heater free of
combustible materials, gasoline, and other flammable
liquids and vapors.
• Heater should never be covered or have any blockage
to the flow of fresh air to the heater.
A WARNING: This unit contains refractory ceramic
fiber (RCF) insulation in the combustion chamber. RCF,
as manufactured, does not contain respirable crystalline
silica. However, following sustained exposure to very
high temperatures [>2192°F (1200°C)], the RCF can
transform into crystalline silica (cristabolite). The
International Agency for Research on Cancer (IARC) has
classified the inhalation of crystalline silica (cristabolite)
as carcinogenic to humans.
When removing the burners or heat exchangers, take
precautions to avoid creating airborne dust and avoid
inhaling airborne fibers. When cleaning spills, use wet
sweeping or High Efficiency Particulate Air (HEPA)
filtered vacuum to minimize airborne dust. Use feasible
engineering controls such as local exhaust ventilation
or dust collecting systems to minimize airborne dust.
Wear appropriate personal
including gloves, safety glasses with side shields, and
appropriate NIOSH-certified
to avoid inhalation of airborne dust and airborne fiber
particles.
4
PRELIMINARY
protective equipment
respiratory protection,
UNCONTROLLED DOCUMENT IF PRINTED
WARNING:
A Improper
alteration, service, or maintenance can cause property
damage, personal injury or loss of life. Installation
and service must be performed by a qualified installer,
service agency, or the gas supplier.
A WARNING: Gasoline, as well as other flammable
materials and liquids (adhesives, solvents, etc.), and
the vapors they produce, are extremely dangerous. Do
not handle, use, or store gasoline or other flammable or
combustible materials in the vicinity of a heater.
WARNING: Both natural gas and propane have
A
an odorant added to aid in detecting a gas leak. Some
people may not physically be able to smell or recognize
this odorant. If you are unsure or unfamiliar with the
smell of natural gas or propane, ask your local gas
supplier. Other conditions, such as "odorant fade,"
which causes the odorant to diminish in intensity, can
also hide, camouflage, or otherwise make detecting a
gas leak by smell more difficult.
A WARNING: UL-recognized fuel gas detectors are
recommended in all enclosed propane and natural
gas applications wherein there is a potential for an
explosive mixture of fuel gas to accumulate and their
installation should be in accordance with the detector
manufacturer's recommendations and/or local laws,
rules, regulations, or customs.
WARNING: Do not install within 3 feet (0.9 m) of
A
a heat pump or an outdoor condensing unit. Strong
air intake from this type of equipment can disturb the
combustion process and cause damage or personal
injury.
A WARNING: The heater shall not be located in an
area where water sprinklers, or other devices, may cause
water to spray through the cabinet louvers and into the
heater. This could cause internal rusting or damage
electrical components. Such damage is not covered
under warranty.
installation, adjustment,