Table of Contents
Advertisement
Quick Links
Owner's Instruction and Operation Manual
Model Number:
AP5622
Report Number: F22-782
Certified to ASTM E1509-12 (2017),
and Certified to ULC-S627-00-REV1
Mobile Home Approved
* All Pictures In This Manual Are For Illustrative Purposes Only. Actual Product May Vary.
Save These Instructions In A Safe Place For Future Reference.
SAFETY NOTICE: If this heater is not properly installed, a house fire may result.
For your safety, follow the installation instructions. Never use make-shift
compromises during the installation of this heater. Contact local building or
fire officials about permits, restrictions and installation requirements in your
area. NEVER OPERATE THIS PRODUCT WHILE UNATTENDED.
CAUTION! Please read this entire manual before you install or use your new room
heater. Failure to follow instructions may result in property damage, bodily injury,
or even death. Improper Installation Could Void Your Warranty!
U.S. Environmental Protection Agency
Certified to comply with 2020 particulate
emissions standards.
THIS MANUAL IS SUBJECT TO CHANGE WITHOUT NOTICE.
© 2022 United States Stove Company, 227 Industrial Park Rd., South Pittsburg, TN 37380
R
CALIFORNIA PROPOSITION 65 WARNING:
This product can expose you to chemicals including carbon
monoxide, which is known to the State of California to cause
cancer, birth defects, and/or other reproductive harm. For
more information, go to www.P65warnings.ca.gov
8 5 3 9 3 1 - 2 3 0 4 L
Ph. 800-750-2723
Advertisement
Table of Contents
Related Manuals for United States Stove Company Ashley AP5622
Summary of Contents for United States Stove Company Ashley AP5622
- Page 1 State of California to cause emissions standards. cancer, birth defects, and/or other reproductive harm. For more information, go to www.P65warnings.ca.gov THIS MANUAL IS SUBJECT TO CHANGE WITHOUT NOTICE. © 2022 United States Stove Company, 227 Industrial Park Rd., South Pittsburg, TN 37380 Ph. 800-750-2723...
- Page 2 1-800-750-2723 Ext 5050 or; available only on the App Store for Text to 423-301-5624 or; iPhone and iPad. Search US Stove. Email us at: Save your receipt with your records customerservice@usstove. for any claims. © 2022 United States Stove Company...
-
Page 3: Installation Checklist
Signed: ___________________________________ Print Name: ______________________________ Date: _____________ Home Owner: RETAIN THIS INFORMATION FOR FUTURE REFERENCE © 2022 United States Stove Company... -
Page 4: Installation
US Stove highly recommends your stove be installed FOOT TRAFFIC AREAS OR PINCH THE CORD by a qualified NFI (US) or WETT (Canada) technician. UNDER FURNITURE. To find the nearest qualified installer, go to: https://nficertified.org, https://www.wettinc.ca/ © 2022 United States Stove Company... -
Page 5: Installation Options
Sidewall to top edge 8” 203 mm Rear (interior of unit 2” 50 mm vertical) H Backwall to flue 3” 76.2mm CORNER J Adjacent wall to unit 8” 203 mm ALCOVE K Alcove depth 36” 914 mm © 2022 United States Stove Company... -
Page 6: Outside Air Supply
In addition to the previously detailed installation WILL NOT FUNCTION PROPERLY. requirements, mobile home installations must meet the following requirements: • This stove must be securely fastened to the floor of the mobile home using two 1/4” lag bolts that © 2022 United States Stove Company... -
Page 7: Maximum Venting Distance
The pellet vent pipe is designed to disassemble for cleaning and should be checked several times during the burning season. The pellet vent pipe is not furnished with the unit and must be purchased separately. © 2022 United States Stove Company... - Page 8 Outside Fresh Air is Mandatory when installing this pellet stove room heater in airtight homes and mobile homes. Be sure that the outside air vent has an approved © 2022 United States Stove Company...
-
Page 9: Through The Wall Installation
Canadian installations must conform to CAN/ elbows rather than 90-degree elbows. CSA-B365. To vent the unit through the wall, connect the pipe adapter to the exhaust motor adapter. If the exhaust adapter is at least 18” (457 © 2022 United States Stove Company... - Page 10 860001, 3-6” transition into 6” connector pipe. the illustration is only an example. Please conform to any local building codes or regulations having jurisdiction before you have a qualified installer proceed with this installation. © 2022 United States Stove Company...
- Page 11 • The levels of heat output will incrementally change on set-point the stove will ramp back up until it the bar graph starting from heat range “1” to heat range reaches the desired temperature. “5”. © 2022 United States Stove Company...
-
Page 12: Control Panel Overview
“Rf-9”. The room fan must operate at a level greater than or equal to the heat range setting. • AUX - USED TO RETURN THE STOVE TO THE FACTORY SETTINGS To return the stove to it’s original factory settings, © 2022 United States Stove Company... - Page 13 T’Stat requires more heat, the unit will begin to feed pellets at the preselected heat setting ranging from “1” to “5”. Use 18 gauge, 2 conductor wire © 2022 United States Stove Company...
-
Page 14: Proper Fuel
We cannot accept ATTENTION: responsibility for damage due to poor quality pellet. THIS APPLIANCE IS DESIGNED FOR THE USE OF PELLETIZED FUEL THAT MEET OR EXCEED THE STANDARD SET BY THE PELLET FUEL INSTITUTE (PFI). © 2022 United States Stove Company... - Page 15 Attempts to achieve heat output MAY ARISE FROM SPARKS OR FUMES rates that exceed heater design specifications can ENTERING THE ROOM. result in permanent damage to the heater. • THE DOOR MUST BE CLOSED AND SEALED DURING OPERATION. © 2022 United States Stove Company...
-
Page 16: Room Air Fan
The stove will shut down and show EXCEPT WHEN REFILLING. “E2” on the two digit display. The stove has to fully • DO NOT OVERFILL HOPPER. shut down before restarting. © 2022 United States Stove Company... -
Page 17: Interior Chambers
(2 screws). The auger motor is located in the center rear of the unit. Note: When cleaning, take care not to damage the fan blades. © 2022 United States Stove Company... -
Page 18: Maintenance
CO bottom. The creosote should be removed with a monitors in areas having the potential to generate brush specifically designed for the type of chimney in use. A qualified chimney sweep can perform this © 2022 United States Stove Company... - Page 19 Glass Wiped Cleaned 5. Re-install the retainer and eight nuts and rope Hopper (end of Empty & gasket using high-temperature silicone to season) Vacuumed adhere the gasket to the door. © 2022 United States Stove Company...
-
Page 20: Troubleshooting Guide
ATTENTION: THIS WOOD HEATER NEEDS PERIODIC INSPECTION AND REPAIR FOR PROPER OPERATION. IT IS AGAINST FEDERAL REGULATIONS TO OPERATE THIS WOOD HEATER IN A MANNER INCONSISTENT WITH OPERATING INSTRUCTIONS IN THIS MANUAL. © 2022 United States Stove Company... -
Page 21: Display Indicators
FACTORY DEFAULTS To return the control to its original factory default settings, press and hold the AUX UP and AUX DOWN buttons together for three seconds. © 2022 United States Stove Company... -
Page 22: Repair Parts
Ignitor Flange Gasket 893241-US Door Handle Kit IN ORDER TO MAINTAIN WARRANTY, COMPONENTS MUST BE REPLACED USING USSC PARTS PURCHASED THROUGH YOUR DEALER OR DIRECTLY FROM USSC. USE OF THIRD PARTY COMPONENTS WILL VOID THE WARRANTY. © 2022 United States Stove Company... -
Page 23: Wiring Diagram
Part numbers and descriptions can be found in the “Repair Parts” section of this manual. Once this information has been gathered you can contact customer service by phone 1-800-750-2723 Ext 5051 or Email parts@usstove.com. Model Information Model Number Serial Number © 2022 United States Stove Company... -
Page 24: Service Record
Engineer Name: _______________________________ Engineer Name: _______________________________ License No.: ____________________________________ License No.: ____________________________________ Company: _____________________________________ Company: _____________________________________ Telephone No.: _________________________________ Telephone No.: _________________________________ Stove Inspected: Chimney Swept: Stove Inspected: Chimney Swept: Items Replaced: _______________________________ Items Replaced: _______________________________ © 2022 United States Stove Company...