Emergency Repairs; What Is Covered By Warranty - Navistar MaxxForce 7 Operation And Maintenance Manual

California Emission System Warranty (cont.)

EMERGENCY REPAIRS

Emergency repairs are recognized if parts are not available
within 30 days or repairs are not completed within 30 days.
If an authorized service provider is not reasonably available,
the vehicle owner or any service establishment can install
replacement parts.
Navistar, Inc. will reimburse you for emergency repairs
(including diagnostics) for the following:
• Replacement parts that do not exceed manufacturer's
suggested retail price
• Labor charges based on manufacturer's recommended time
allowance and geographic hourly rate
Replaced parts and paid invoices must be given to your dealer
for reimbursement of emergency repairs.

WHAT IS COVERED BY WARRANTY

Where a warrantable condition exists, Navistar, Inc. will repair
your diesel engine at no cost to you including diagnosis,
parts, and labor. If your (vehicle or truck) fails a Smog Check
inspection, all necessary repairs and adjustments will be
made by Navistar to ensure that your emission control system
Performance Warranty.
If any emission-related part on your diesel engine is defective,
the part will be repaired or replaced by Navistar. This is your
WARRANTY
short-term emission control system Defects Warranty.
diesel-powered heavy-duty vehicles (except medium-duty
vehicles), and motor vehicle engines used in such vehicles, a
period of use of five years, 100,000 miles, or 3000 hours of
operation, whichever first occurs. However, in no case may
this period be less than the basic mechanical warranty that the
manufacturer provides (with or without additional charge) to the
purchaser of the engine. Extended warranties on select parts do
not extend the emissions warranty requirements for the entire
engine but only for those parts. In cases where responsibility
for an extended warranty is shared between the owner and the
manufacturer, the emission warranty shall also be shared in the
same manner as specified in the warranty agreement.
New vehicles and engines, registered and certified for sale in
California, have the following items covered by the emission
warranty when first installed on the engine as original equipment:
• Fuel injection system
• Air induction system (includes turbocharger, exhaust
manifold, Exhaust Gas Recirculation [EGR] system, EGR
rate and feedback control system, and intake manifold)
• Positive crankcase ventilation system (includes Crankcase
Ventilation Valve [CCV] and oil fill cap)
For
Page 11