Table Of Contents - Heat & Glo 6000C-IFT Installation Manual

Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Used to address practices not related to personal injury.
Note: The term "recommend" or "recommended" does not indicate a requirement. It is a best practice suggested by Hearth
& Home Technologies
Installation Standard Work Checklist . . . . . . . . . . . . . . . . . . . . 3
1 Product Specific and Important Safety Information
A. Appliance Certification . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
B. Tempered Glass Specifications . . . . . . . . . . . . . . . . . . . . . 4
C. BTU Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . . 4
E. Non-Combustible Materials Specification. . . . . . . . . . . . . . 5
F. Combustible Materials Specification . . . . . . . . . . . . . . . . . 5
G. Electrical Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
H. California . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
I. Requirements for the Commonwealth of Massachusetts . . 6
2 Getting Started
A. Design and Installation Considerations . . . . . . . . . . . . . . . 7
B. Good Faith Wall Surface . . . . . . . . . . . . . . . . . . . . . . . . . . 7
C. Tools and Supplies Needed . . . . . . . . . . . . . . . . . . . . . . . . 7
D. Inspect Appliance and Components . . . . . . . . . . . . . . . . . . 8
3 Framing and Clearances
A. Appliance/Decorative Front Dimension Diagrams . . . . . . . 9
B. Clearances to Combustibles . . . . . . . . . . . . . . . . . . . . . . 15
C. Constructing the Appliance Chase . . . . . . . . . . . . . . . . . . 17
4 Termination Location and Vent Information
A. Vent Termination Minimum Clearances . . . . . . . . . . . . . . 18
B. Vent Terminal Clearances . . . . . . . . . . . . . . . . . . . . . . . . 19
C. Approved Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
D. Use of Elbows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
E. Measuring Standards . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
F. Vent Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
5 Vent Clearances and Framing
A. Pipe Clearances to Combustibles . . . . . . . . . . . . . . . . . . 36
B. Wall Penetration Framing/Firestops . . . . . . . . . . . . . . . . . 37
C. Ceiling Firestop/Floor Penetration Framing . . . . . . . . . . . 38
D. Install Attic Insulation Shield . . . . . . . . . . . . . . . . . . . . . . . 38
6 Appliance Preparation
A. Vent Collar Preparation . . . . . . . . . . . . . . . . . . . . . . . . . . 39
B. Installing Optional Heat Management Systems . . . . . . . . 41
C. Securing and Leveling the Appliance . . . . . . . . . . . . . . . . 42
D. Installing the Non-combustible Board. . . . . . . . . . . . . . . . 42
2
®
. Failure to perform the recommended task will not result in a safety concern.

Table of Contents

Heat & Glo • 6000C-IFT, 8000C-IFT Installation Manual • 2502-980 Rev. M • 3/21
7 Venting and Chimneys
A. Assemble Vent Sections (DVP Only) . . . . . . . . . . . . . . . 43
B . Assemble Vent Sections (SLP Only) . . . . . . . . . . . . . . . . 44
C. Assemble Slip Sections . . . . . . . . . . . . . . . . . . . . . . . . . . 44
D. Secure the Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . . 45
E. Disassemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . 45
F. Vertical Termination Requirements . . . . . . . . . . . . . . . . . . 46
G. Horizontal Termination Requirements . . . . . . . . . . . . . . . 47
8 Electrical Information
A. General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
B. Wiring Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
9 Gas Information
A. Fuel Conversion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
B. Gas Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
C. Gas Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . 52
E. Air Shutter Setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
10 Finishing
A. Facing Material . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
B. Mantel and Wall Projections . . . . . . . . . . . . . . . . . . . . . . . 55
C. Decorative Fronts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
11 Appliance Setup
A. Remove Fixed Glass Assembly . . . . . . . . . . . . . . . . . . . . 59
B. Remove the Shipping Materials . . . . . . . . . . . . . . . . . . . . 59
C. Clean the Appliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
D. Front Base Refractory Placement . . . . . . . . . . . . . . . . . . 59
E. Burner Top Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
F. Install the Refractory (Optional) . . . . . . . . . . . . . . . . . . . 60
G. Ember Placement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
H. Install the Log Assembly. . . . . . . . . . . . . . . . . . . . . . . . . . 61
I. IntelliFire Touch Control System Setup . . . . . . . . . . . . . . 65
®
J. Install Fixed Glass Assembly . . . . . . . . . . . . . . . . . . . . . . 65
K. Install Decorative Front . . . . . . . . . . . . . . . . . . . . . . . . . . 65
12 Reference Materials
A. Vent Components Diagrams . . . . . . . . . . . . . . . . . . . . . . 66
B. Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
 = Contains updated information.
