Index; Instrumentation; Manufacturer Reserves The Right To Discontinue, Or Change At Any Time, Specifications Or Designs Without Notice And Without Incurring Obligations - Carrier AQUAFORCE 30XW150-400 Operation & Service Manual

4-20 mA temperature reset
Actual start-up
47
Alarms and alerts
68
Alarm control
42
Equipment priority
42
Routing control
42
System name
43
Board addresses
17
Brine or glycol operation
27
Broadcast acknowledger
20, 42
Broadcast configuration
41
Capacity control overrides
43
Carrier Comfort Network ® (CCN)
Interface
18
Loadshed controlled demand limit
Tables
118-132
Chilled water flow switch
66
Chilled water fluid type selection
Circuit/compressor staging
and loading
29
Loading
29
Staging
29
Communication failure retry time
Compressor
Assembly
63
Oil system
63
Protection
10,67
Compressor protection
module (CPM)
10
Configuration
18-46
Control module communication
Controls
9-18
Conventions used in this manual
Cooler
64
Pump control
28
Cooling set point selection
CPM DIP switch addresses
Daylight saving time configuration
Demand limit
39
Externally powered capacity based
Externally powered current based
Switch controlled
39
Diagnostic alarm codes
and possible causes
73
Display module usage
3
Dual chiller control
29
For parallel applications
For series applications
33
Pump control for parallel
chiller applications
33
Pump control for series
chiller applications
35
Dual chiller sequence of operation
Dual pump and manual control
Economizer assembly
59
Electronic expansion valve (EXV)
EXV board
13
EXV control
60
Main EXV control
59
Troubleshooting procedure
Emergency on/off switch (SW2)
Enable-off-remote contact
switch (SW1)
16
Energy Management Module (EMM)
Entering fluid control option
Flow rate requirements
47
Freeze protection
43,76
Fresh water
27
General (Controls)
9
Green LED
17
Head pressure control
46
Heat exchangers, inspecting/cleaning
Ice storage operation
41
Leak testing
67
Copyright 2009 Carrier Corporation

Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations.

Catalog No. 04-53300024-01
36
18
41
27
42
17
3
25
133,134
43
40
40
30
54
28
59
61
16
16
25
66
Printed in U.S.A.

INDEX

Local equipment network
Loss of fluid flow protection
Low condenser fluid temperature
head pressure control
Operating instructions
Option
46
Low fluid temperature
Machine control methods
Machine on/off control
Machine start delay
Main Base Board (MBB)
Maintenance
67
Minimum fluid loop volume
Minimum load control
MLV/condenser board
Navigator™ display module
Machine control
Navigator display tables
No pump control
Operating limitations
Operating modes
Operation
54-59
Piping and instrumentation
Pressure relief valves
Pre-start-up
46
Pump operation
54
Ramp loading
35
Re-alarm time
43
Recommended maintenance schedule
Red LED
17
Refrigerant charge
Refrigerant circuit
Relief devices
67
Remote alarm and alert relays
Retubing
65
Return water reset
Safety considerations
Safety devices
67
Sensors
56
Sequence of operation
Service
59-67
Service test
83
Set point occupancy
Single pump control
Space temperature reset
Start-up
47-53
Start-up checklist for
30XW liquid chillers
Suction service valve
System check
46
Temperature reset
Thermistors
56
Tightening cooler head bolts
Touch Pilot display
Display tables
Machine control
Operation configuration tables
Transducers
56
Troubleshooting
67-85
Tube plugging
65
Voltage
47
Water treatment
66
Yellow LED
17
Form 30XW-1T
17
65
46
46
65
20
20
29
9
47
29
15
7
23
105-117
28
47
54
135, 136
67
67
67
67
18
35
2
54
25
28
36
CL-1 to CL-7
64
35
65
3,17
86-104
20
18
Pg 140 11-09 Replaces: New