Table of Contents
Advertisement
Quick Links
H15U-NG/LP Direct Vent Gas Fireplace
MODELS:
H15U-NG Natural Gas
WARNING:
If the information in these instructions are not
followed exactly, a fire or explosion may result
causing property damage, personal injury or loss
of life.
FOR YOUR SAFETY
Do not store or use gasoline or other flammable
vapours and liquids in the vicinity of this or any
other appliance.
Installation and service must be performed by
a qualified installer, service agency or the gas
supplier.
Tested by:
Installer: Please complete the details on the back cover and leave this manual with the homeowner.
Homeowner: Please keep these instructions for future reference.
FPI FIREPLACE PRODUCTS INTERNATIONAL LTD. 6988 Venture St., Delta, BC Canada, V4G 1H4
920-425
H15U-LP Propane
FOR YOUR SAFETY
What to do if you smell gas:
• Do not try to light any appliance.
• Do not touch any electrical switch.
Do not use any phone in your
building.
• Immediately call your gas supplier
from a neighbour's phone. Follow
the gas supplier's instructions.
• If you cannot reach your gas
supplier, call the fire department.
Owners &
Installation Manual
www.hampton-fire.com
This appliance may only be
installed in an aftermarket
p e r m a n e n t l y
manufactured (USA only)
or mobile home, where not
prohibited by local codes.
This appliance is only for use
with the type of gas indicated
on the rating plate. This
appliance is not convertible for
use with other gases, unless
a certified kit is used.
l o c a t e d ,
02.18.22
Advertisement
Table of Contents
Related Manuals for HAMPTON BAY H15U-NG
Summary of Contents for HAMPTON BAY H15U-NG
- Page 1 Owners & H15U-NG/LP Direct Vent Gas Fireplace Installation Manual www.hampton-fire.com MODELS: H15U-NG Natural Gas H15U-LP Propane WARNING: FOR YOUR SAFETY This appliance may only be If the information in these instructions are not installed in an aftermarket What to do if you smell gas:...
- Page 2 H15U-NG/H15U-LP are hand crafted appliances designed to provide you with all the warmth and charm of a wood fire- place at the flick of a switch. The H15U-NG/LP models are approved by Warnock Hersey for safety and efficiency. As they also bear Regency's mark, they will provide you with economy, comfort and security for many trouble-free years to follow.
-
Page 3: Table Of Contents
Horizontal Termination Installations ..........27 Burner & Log Assembly ..............48 Dura-Vent Termination Kit - Planning Your Dura-Vent Installation ..28 Warranty Horizontal Terminations ..............29 Vertical Terminations ................. 30 Offset Chart ..................31 Warranty .................... 50 Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 4: Unit Dimensions With Horizontal Vent
Unit Dimensions with Horizontal Vent " 525mm " 481mm ALL PICTURES / DIAGRAMS SHOWN THROUGHOUT THIS MANUAL ARE FOR ILLUSTRATION PURPOSES ONLY. ACTUAL PRODUCT MAY VARY DUE TO PRODUCT ENHANCEMENTS. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 5: Unit Dimensions With Vertical Vent
Unit Dimensions with Vertical Vent " 525mm " 433mm Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 6: Safety Label
With the panel removed, the gas valve will be visible. The rating plate will be attached to a black chain located under the IFC. DO NOT REMOVE THE DECAL FROM THE UNIT. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... - Page 7 (e) A copy of all installation instructions for all Product Approved side wall horizontally vented gas fueled equipm ent, all venting instructions, all parts lists for venting instructions, and/or all venting design instructions shall remain with the appliance or equipment at the completion of the installation. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove...
-
Page 8: Gas Installation Checklist
Does the supply pressure meet the requirements shown on the rating plate? Was a conversion performed? Was a leak check performed and manifold pressures verified? Is the shut-off valve installed and easily accessible to the customer? Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... - Page 9 Are the model and serial numbers and the date of installation of the unit written in the manual and on the checklist? Were the warranty and unit registration reviewed with the customer? Comments: Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove 05/18/21...
-
Page 10: Copy Of The Lighting Plate Instructions
DO NOT REMOVE THIS INSTRUCTION PLATE NE PAS ENLEVER CETTE ÉTIQUETTE D’INSTRUCTIONS 920-181a Part #: 920-181a Colours: Black on Grey, except for parts indicated as being Red. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove Punch out .25" hole top right corner where indicated. Size: 100%... -
Page 11: Important Message
This appliance is not convertible for use with Specifications other gases, unless a certified kit is used. Fuels: H15U-NG is approved for use with natural Before You Start gas. YOUNG CHILDREN SHOULD BE CARE- FULLY SUPERVISED WHEN THEY ARE... -
Page 12: General Safety Information
8) Final check. Refer to the "Final Check" section. carpeting. 4) See general construction and assembly in- structions. The appliance and vent should be Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 13: Clearances To Combustibles
Combustion and Ventilation The combustion air from this appliance is drawn from outside the building through the outer flue. Extra provision for combustion air inside the room is not required. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 14: Optional Fan Installation
Ground Lug for ‘‘Mobile use only’’ 9) Re-attach control panel w ith screws r eversing 4) Remove the Top Control Panel Assembly by step 4. removing the three screws. Nylon Plug 920-474 11.24.21 Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... - Page 15 This appliance is equipped with a three pronged (grounding) plug for your protection against shock hazard and should be plugged directly into a properly grounded three-prong receptacle. Do not cut or remove the grounding prong from this plug. 11.24.21 920-474 Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove...
-
Page 16: Venting Introduction
3) Be aware of electrical wiring locations in walls These venting systems are engineered products and ceilings. that have been designed and tested for use with the H15U-NG and H15U-LP. The warranty will be voided Rotating Elbow 3) Unhook the back panel. 5) Rotate the elbow 180 degrees. -
Page 17: Exterior Vent Terminal Locations
* Clearance in accordance with local installation codes and the requirements of the gas supplier 3 feet (91cm) within a height of 15 feet (4.5m) above the meter / regulator assembly 3 feet (91cm) above - if within 10 feet (3m) horizontally Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 18: 4" X 6-5/8" (102 Mm X 168 Mm) Rigid Pipe Cross Reference Chart
4DWT 4DWT SV4RSM VDV-WPT04 Wal l Thimble Cover/Ceiling Support 46DVA-DC SV4PF Firestop Spacer 46DVA-FS 4DT-FS 4DFSP 4DFS SV4BF TM-4CS VDV-FS04 Trim Plate-Black 4DT-TP 4DFPB 4DcP SV4LA TM-4TP VDV-WTC04 * Not available from Regency Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... - Page 19 Note: Horizontal runs of vent must be level, or have a 1/4” rise for every 1 foot of run towards the termination. Never allow the vent to run downward - this could cause high temperatures and may present a possible fire hazard. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove...
-
Page 20: Rigid Pipe Venting Systems
American Metal Products Ameri Vent Direct Vent, Security Secure Vent ® , Selkirk Direct-Temp. AstroCap is a proprietary trademark of FPI Fireplace Products International Ltd. Dura-Vent® and Direct Vent are registered and/or proprietary trademarks of Simpson Dura-Vent Co. Inc. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 21: Horizontal Venting With Two (2) 90 Elbows
Please note min. 1 foot between 90 elbows is 5' Max. 8' Min. 8' Max. required. Lengths do not include elbow indicated Vent restrictor position A (fully open), refer to the "Vent Restrictor Postion" section. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 22: Vertical Venting With Two (2) 90 Elbows
Please note min. 1 foot 5' Max. 5' Min. between 90 elbows is 6' Max. 6' Min. required. Lengths do not include elbow indicated Vent restrictor position A (fully open), refer to the "Vent Restrictor Postion" section. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 23: Venting Arrangements
The two diagrams show all allowable combinations of straight horizontal termination with one 45 elbow off the unit. Restrictor position "A". 12" max. w/AstroCap or Simpson Duravent Hori- zontal Square Termination Cap. 24" max. w/FPI Riser or Snorkel Termination Cap. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 24: Vertical Termination With Co-Linear Flex System
Co-linear Flex System for Residential & Manufactured Homes into Masonry Fireplaces The shaded area in the diagram shows the allowable vertical terminations. Straight Vertical Terminations Vent Restrictors set at fully closed, Position "B" Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 25: Dv Stove Horizontal Vent Kit
DV 2 ft. Stove Vent Kit (Part # 946-116) and DV 4 ft. Stove Vent Kit (946-216) includes all the parts needed to install the H15U-NG/H15U-LP Direct Vent unit with up & out horizontal and vertical vent dimensions. For installations that require longer vertical and/or horizontal vents use the Dura-Vent system as shown in the "Dura-Vent Termination Kit"... - Page 26 1-1/2" drill point, black) to the wall. 11) Slide the 90 elbow (crimp end up), the 45 elbow and the 4 ft. pipe section (crimp end up) over the 4" dia. flex liner. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove...
-
Page 27: Residential And Manufactured Homes / Mobile Homes Minimum Horizontal Termination Installations
NOTE: Ensure compliance with the outside vent Square Wall Thimble Cover* terminal location before cutting hole as both dimen- Snorkel Termination (36") sions must be met. Snorkel Termination (14") Wall Penetration Heat Shield* * Simpson Dura-Vent Components Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 28: Dura-Vent Termination Kit - Planning Your Dura-Vent Installation
FPI venting systems as well as Simpson Dura-Vent® and Direct Vent. The FPI AstroCap is a proprietary trademark of FPI Fireplace Products International Ltd. Dura-Vent® and Direct Vent are registered and/or proprietary trademarks of Simpson Dura-Vent Co. Inc. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 29: Horizontal Terminations
“Mill-Pac” sealant (supplied) to every inner pipe connection. Failure to do so may result in drafting or performance issues not covered under warranty. Silicone (red RTV) is optional. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 30: Vertical Terminations
See diagram 5. 9) Slide the decorative wall thimble up to the wall surface being careful not to scratch the paint. See diagram 5. Diagram 7 Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 31: Offset Chart
Failure to do so including closets and storage spaces, may result in drafting or performance through which the vertical vent passes, issues not covered under warranty. must be enclosed. Silicone (red RTV) is optional. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 32: Converting Class-A Metal Chimney To Direct Vent System
3 and 4). Diagram 5 7) The connection between the appliance and the Diagram 2 Retro Connector may be completed with sec- tions of black direct vent pipe, together with an adjustable length. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 33: Cathedral Ceilings Round Support (Rds) & Square Support (Sqs)
3) Use appropriate roof flashing. Place the flash- ing under the upper shingles and on top of the lower shingles approximately half of the flashing should be under the shingles. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 34: Aeration Adjustment
(clockwise) with a 1/8" flat screwdriver. Closed - Tall yellow Note: Screw should be snug, but do not over Open - Short Blue tighten. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 35: Conversion Kit# 381-969 From Ng To Lp
17) Attach the label "This unit has been converted to LPG" near or on top of the serial # decal. 18) Replace yellow "Natural Gas" label with red "LPG" label. Fig.4 02/18/22 920-467 Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... - Page 36 21) Plug up the Piezo hole with the plastic the orifi ce. bushing. 918-479 04/21/06 Before Burner Orifi ce 15) Reinstall new burner orifi ce LP stamped #55 and tighten. After 918-479 04/21/06 Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove...
-
Page 37: Log Set Installation
2 screws using a 7/16" wrench. Pull front out and then up as shown below. Inside view Left Front Log Right Front Log 4) Remove Glass front - see instructions in manual. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove Side 1 of 2 918-228a 03/31/15... - Page 38 fl ows smoothly from one end of burner to the other). If there is any fl ame hesitation, check that area for any blockage of the burner ports. 11) Re-install the Glass Front, Cast Front and Top. Side 2 of 2 918-228a 03/31/15 Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove...
-
Page 39: Optional Wall Thermostat
Recommended Maximum Lead Length (Two-Wire) When Using Wall Thermostat (CP-2 System) Wire Size Max. Length 14 GA. 50 Ft. 16 GA. 32 Ft. 18 GA. 20 Ft. 20 GA. 12 Ft. 22 GA. 9 Ft. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 40: Wiring Diagrams
This appliance is equipped with a three pronged (grounding) plug for your protection against shock hazard and should be plugged directly into a properly grounded three-prong receptacle. Do not cut or remove the grounding prong from this plug. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 41: Final Check
Use a non-abrasive cleaner and 7) The unit should never be turned off, and on NEVER clean the glass while it is hot. again without a minimum of a 60 second wait. Lighting Procedure Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 42: Copy Of The Lighting Plate Instructions
DO NOT REMOVE THIS INSTRUCTION PLATE NE PAS ENLEVER CETTE ÉTIQUETTE D’INSTRUCTIONS 920-181a Part #: 920-181a Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove Colours: Black on Grey, except for parts indicated as being Red. Punch out .25" hole top right corner where indicated. -
Page 43: Maintenance
WHICH HAS BEEN UNDER WATER. 3) The heater is finished in a porcelain finish or with a heat resistant paint and should only be refinished with heat resistant paint (not with wall paint). Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 44: General Vent Maintenance
4) Re-install Cast Top. WARNING: Do not operate appliance with glass panel removed, cracked or broken. Replacement of the glass should be done by a licensed or quali- fied service person. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 45: Removing Valve
11-20. 6) Lift off Cast Top, remove Cast Front and remove Glass Door. See the "Glass Replacement" sec- tion for removal instructions. 7) Carefully remove the logs and embers. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 46: Gas Maintenance - Recommended Annual Routine
Burner media (change as needed) • Thermocouple (millivolt models) • Air shutter setting • Thermopile (millivolt models) • Wiring Gas Leak Tests • Check main gas line connection to valve • Check shut off valve connections • Check connection at gas valve outlet • Check connection at main burner orifice • Check pilot fuel line at valve and at pilot assembly 920-324 09.14.20 Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 47: Parts
Top Front Grill Timberline Brown 920-447 Decal Control Panel Front Hi-Lo 383-237 Top Front Grill Cream & Pilot 384-007 Rear Panel 384-017 Valve Cover Bottom 280-033 Control Panel Top Rear 380-007 Door Frame Only Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... -
Page 48: Burner & Log Assembly
938-337 Touch Up Paint - Cream 382-022 Front Top Cast Mounting Bracket Left 382-023 Front Top Cast Mounting Bracket Right 382-001 Firebox Side Bracket Left 382-002 Firebox Side Bracket Right 920-425 Instruction Manual Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... - Page 49 Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove...
-
Page 50: Warranty
FPI is not responsible for results or costs of workmanship of unauthorized FPI dealers or agents in the negligence of their service work. Revision Date: February 2019 Regency Gas Products Warranty Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove... - Page 51 Freight damages for products or parts are not covered under the terms of the warranty. Products made or provided by other manufacturers and used in conjunction with the FPI appliance without prior authorization from FPI may void this warranty. Revision Date: February 2019 Regency Gas Products Warranty Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove...
- Page 52 To provide the best support for your product, we request that you complete a product registration form at http://www.regency-fire.com/Customer-Care/Warranty-Registration.aspx within ninety (90) days of purchase. Revision Date: February 2019 Regency Gas Products Warranty Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove...
- Page 53 For fireplace care and tips and answers to most common questions please visit our Customer Care section on our Web Site. Please feel free to contact your selling dealer if you have any questions about your Regency product. Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove...
- Page 54 Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove...
- Page 55 Hampton® H15U-NG/LP Direct Vent Freestanding Gas Stove...
- Page 56 Installer: Please complete the following information Dealer Name & Address: ______________________________________________ ___________________________________________________________________ Installer: ___________________________________________________________ Phone #: ___________________________________________________________ Date Installed: ______________________________________________________ Serial #: ____________________________________________________________ Hampton is a trademark of FPI Fireplace Products International Ltd. Printed in Canada © Copyright 2022, FPI Fireplace Products International Ltd. All rights reserved.
Need help?
Do you have a question about the H15U-NG and is the answer not in the manual?
Questions and answers