Contents Warnings..............3 Technical data ............4 Gas category ...............4 Exploded drawing ............5 Parts list ..............6 Hardware ..............7 Assembly instructions ...........8 Gas leak test ............18 Connecting gas ............19 Lighting instructions ...........20 Before using the grill........... 22 Warnings ..............23 Maintenance .............24 Troubleshooting ............25 Consumer Contact .............26...
WARNINGS Failure to follow the instructions provided can imply a risk of serious injury to personnel and fixed installations. Some grill parts can be sharp, we recommend wearing gloves when assembling and lifting. Sharp edges can cause injury. The grill is intended for outdoor use only in well-ventilated areas. Never grill in enclosed spaces or under a roof, due to the danger of the lack of oxygen.
Technical data — Key West 4+1 Total effect: 17 kW (main burner heat input 14 kW (1020 g/h, side burner heat input: 3 kW (218g/h) Total gas consumption: 1235 g/h. Hose and regulator (not included): Must be approved according to EN standard.
Parts list seq. NO appellation Lid assembly Thermometer Lid handle Cushion rubber Warming rack Insert system basic grill Cast iron grill 240mm Heat distribution panel Clip to the tube burner Tube burner Grease cup holder Grease cup Grease tray Side burner cooking grid Side burner assembly Cart Left side panel Door magnet Cart front beam Cart rear panel Cart bottom panel Cart right side panel Bottom panel decoration strip Cart triangular support bracket Lockable caster Door Gas connection nozzle Main burner control knob Side burner control knob Control panel assembly Firebox assembly Side table Insert system round grill ...
Hardware The following screws and nuts are supplied with the grill and must be fitted. TOOLS FOR ASSEMBLING (NOT INCLUDED) Ruler Medium size flat blade or Adjustable spanner or Philips/cross-point screwdriver metric spanner set WARNING! Exercise caution when using electric tools – their strength can damage the screws.
IMPORTANT! GAS LEAK TEST ALL JOINTS AND CONNECTIONS MUST NOW BE LEAK TESTED BEFORE USING THE GRILL. Leak test annually, and whenever the gas bottle is removed or replaced. Always perform a leak test in a well-ventilated area. Make a mixed solution (½...
Connecting the gas ALWAYS perform a gas leak test before using the grill. Hose Gas bottle Check the gas hose regularly Connect the gas hose to the gas for cracks, damage and de- rail inlet on the left hand side of the cay.
Lighting instructions Key West 4+1 The lid must be open when lighting the burner. Do not MANUAL IGNITION stand with your face directly over the gas grill when MANUELL- If the grill will not light using the lighting it. Your gas grill will have following method of ignition: PILOT GAS CONTROL IGNITION: normal lighter, use the following procedure for manual lighting.
Page 21
IGNITION OF SIDE BURNER: To get the maximum yield with the minimum Flames should be blue consumption of gas it is handy to keep the following and stable. If the flames are points in mind: large and yellow, flaring or Once the burner has been alighted, adjust the flame ’broken’, check the according to your needs, from “Maximum”...
Before using the grill LOCATION Grilling tips A CLEAN GRILL WORKS BETTER, causes less smoke Ensure that the grill is and prevents fat catching fire. Burn off the grill after placed at least 150cm use by opening the lid and burning all the burners at in all directions from house full power for 10 minutes.
WARNING! Always keep an eye on the grill when Disconnect the gas bottle when the in use. Never allow children or others who grill is in use or before moving it. require supervision near the grill when in use. If storing the grill in a garage or basement below ground level, do not store This grill is only intended for outdoor the gas bottle the same place, as it must be...
Maintenance and cleaning MAINTENANCE CLEANING Check that the burners are Use clean water only. A mild washing up burning correctly regularly. liquid can be added for general cleaning. Do not use flammable cleaning agents. Remove the grill grate and flame guards.
Troubleshooting PROBLEM POSSIBLE CAUSE SOLUTION Empty gas bottle Replace gas bottle Damaged regulator Check/replace the regulator Burner is blocked Clean the burner Gas supply is blocked Clean gas ventury or hose Burner will not light when using the ignition knob Electrode is broken or dirty Clean the electrode Ignition knob is broken...
CONSUMER CONTACT Nordic Season Products AS Kjeller Vest 3, 2007 Kjeller 031 189095 +47 924 78600 support@nordicseason.no www.nordicseason.no Always attach your receipt and product serial number when making a warranty claim. Produced in China for Nordic Season Products AS.