Related Manuals for NORDIC SEASON Hamilton 3.0
Summary of Contents for NORDIC SEASON Hamilton 3.0
- Page 1 Hamilton 3 BURNER GAS BBQ GG202030 READ THE OPERATING INSTRUCTIONS BEFORE USING THE APPLIANCE. FOR OUTDOOR USE ONLY. INSTRUCTION AND USER MANUAL OUTDOOR USE ONLY!
-
Page 2: Table Of Contents
Gas category ...................4 Exploded drawing................5 Parts list ...................6 Hardware ..................7 Assembly instructions ..............8 Gas leak test .................16 Connecting gas ................17 Before using the grill ..............18 Grilling tips..................19 Lighting instructions ...............20 Warnings ..................21 Maintenance................... 22 Troubleshooting ................23 Consumer Contact .................24 Hamilton 3.0... -
Page 3: Warnings
WARNINGS Failure to follow the instructions provided can imply a risk of serious injury to personnel and fixed installations. Some grill parts can be sharp, we recommend wearing gloves when assembling and lifting. Sharp edges can cause injury. The grill is intended for outdoor use only in well-ventilated areas. Never grill in enclosed spaces or under a roof, due to the danger of the lack of oxygen. -
Page 4: Technical Data
LPG 28~30 mbar and TR G30 (butane), AT, DE, CH, LU and Grill burner: G31(propane) I3B/P(50) 0.68mm and mixture of these, LPG 50mbar This product is produced according to EUROPEAN GAS APPLIANCE STANDARD EN498 AND EN484 and is CE certified. Hamilton 3.0... -
Page 5: Exploded Drawing
Exploded Drawing... -
Page 6: Parts List
Ignition Grease Tray Right Side Table Side Table Left Decoration Panel Cylinder Belt Bottom Shelf Right Rear Leg Right Front Leg Leg and Cap Knob When ordering spare parts, please use the code from parts list found here. Hamilton 3.0... -
Page 7: Hardware
Hardware The following screws and nuts are supplied with the grill and must be fitted. 16 pcs M6x65 screw 18 pcs M6x12 screw 2 pcs M5x12 screw 2 pcs 2 pcs... -
Page 8: Assembly Instructions
To have a simplify packaging, the fat tray is turned around and placed underneath of firebox, please take out the fat tray when you take out the firebox and install the fat tray with correct way as step 7. Hamilton 3.0... - Page 9 Assembly Plug the leg end cap into right front and rear legs before attach to firebox. Attach the 4 legs to firebox with 8pcs of screw A. Attach the beam to 4 legs with 8pcs of screw A. M6 x 65, 16 pcs...
- Page 10 Innehållsförteckning Assembly Attach the wheels to legs with 2pcs of axle D and 2pcs of lock nut E as shown below, then put on the wheel cover. 2 pcs 2 pcs Hamilton 3.0...
- Page 11 Assembly Attach the bottom shelf to beam with 4pcs of screw B M6 x 12 screw, 4 pcs...
- Page 12 Innehållsförteckning Assembly Attach the front panels to front legs with 8pcs of screw B M6 x 12 screw, 8 pcs Hamilton 3.0...
- Page 13 Assembly Attach the side table decoration panel to side table with 2 pcs of screw B for each side. Loosen the screws A between legs and firebox about 5mm, then hook on the side tables right in place, and tighten again the screw A. Fix the side table decoration panel to control panel with 1pc of screw C on each side.
- Page 14 Open the lid and put four flame tamers into the grill housing. Place cooking grid and warming rack in the grill housing as shown below. Ensure the grids are installed above the flame tamers. M6x12 screw, 2 pcs Hamilton 3.0...
- Page 15 Assembly Attach the grease tray to firebox ASSEMBLY IS NOW COMPLETE. ALL JOINTS AND CONNECTIONS MUST BE LEAK TESTED BEFORE USING THE GRILL. READ CAREFULLY LEAK TESTING ON PAGE 16.
-
Page 16: Gas Leak Test
IF BUBBLES APPEAR, SWITCH OFF THE GAS SUPPLY AND REPAIR THE PROBLEM. PERFORM A NEW LEAK TEST. DO NOT USE THE GRILL BEFORE YOU ARE SURE THAT THERE ARE NO LEAKS. If there are still gas leaks after repeated attempts, contact your dealer. Hamilton 3.0... -
Page 17: Connecting Gas
Connecting Gas ALWAYS perform a gas leak test before using the grill. Hose Gas bottle Check the gas hose regularly Connect the gas hose to the gas for cracks and decay. Never rail inlet on the left hand side of the use a damaged gas hose. -
Page 18: Before Using The Grill
Check that the gas hose is free of cracks and damage (it should always be done before using the grill). Check that the gas bottle and hose do not come into contact with hot objects. Hamilton 3.0... -
Page 19: Grilling Tips
Grilling tips A CLEAN GRILL WORKS BETTER, causes less smoke and prevents fat catching fire. Burn off the grill after use by opening the lid and burning all the burners at full power for 10 minutes. Allow the grill to cool, and then brush off ash from flame tamers and grates. -
Page 20: Lighting Instructions
Switch off the gas supply at the bottle, then turn all control valves to the NEVER DOUSE THE “Off” position. GRILL WITH WATER Wait until the barbecue is sufficiently cool WHEN THE SURFACES before closing the hood. ARE HOT. Hamilton 3.0... -
Page 21: Warnings
WARNING Always keep an eye on the grill when in If storing the grill in a garage or use. Never allow children or others who require basement below ground level, do not store the supervision near the grill when in use. gas bottle the same place, as it must be stored above normal ground level. -
Page 22: Maintenance
When using a grill cover, the grill must be clean when they are dry. and dry and sufficient ventilation must be ensured. If not, moisture will accumulate under the cover causing Check that the gas hose is not rust damage. damaged by mice or rats. Hamilton 3.0... -
Page 23: Troubleshooting
Troubleshooting PROBLEM POSSIBLE CAUSE SOLUTION Empty gas bottle Replace gas bottle Damaged regulator Check/replace the regulator Burner is blocked Clean the burner Gas supply is blocked Clean gas ventury or hose BURNER WILL NOT LIGHT Electrode is broken or dirty Clean the electrode Place the BBQ in a less Windy conditions... -
Page 24: Consumer Contact
Always attach your receipt and product serial number when making a warranty claim. This can be found of the carton or the CE-label. We reserve the right for any misprints or changes in the specifications. Produced in China for Nordic Season Asia Co., Ltd. Hamilton 3.0...