Genie Z-45/22 Service Manual page 8

TABLE OF CONTENTS
Section Five Troubleshooting Flow Charts
Introduction ............................................................................................................... 5 - 1
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
viii
Engine Will Not Crank Over ............................................................................ 5 - 3
Engine Cranks But Will Not Start - Gasoline/LPG Models .............................. 5 - 4
Engine Cranks But Will Not Start - Diesel Models .......................................... 5 - 9
Engine Choke Inoperative - Gasoline/LPG Models ....................................... 5 - 11
Engine Glow Plugs Inoperative - Diesel Models
See B-11, Check The Glow Plugs ................................................................ 4 - 15
Engine Will Not Start On LPG, But Will Start On Gasoline
- Gasoline/LPG Models ................................................................................. 5 - 13
Engine Will Not Start On Gasoline, But Will Start On LPG
- Gasoline/LPG Models ................................................................................. 5 - 14
Engine High Idle Inoperative - Gasoline/LPG Models ................................... 5 - 15
Engine Low Idle Inoperative - Gasoline/LPG Models .................................... 5 - 17
Engine High Idle Inoperative - Diesel Models ............................................... 5 - 18
Engine Low Idle Inoperative - Diesel Models ................................................ 5 - 19
All Functions Inoperative, Engine Starts and Runs ....................................... 5 - 20
All Lift and Steer Functions Inoperative, Drive Functions Operational .......... 5 - 21
Ground Controls Inoperative, Platform Controls Operate Normally .............. 5 - 22
Platform Controls Inoperative, Ground Controls Operate Normally .............. 5 - 23
Secondary Boom Up Function Inoperative ................................................... 5 - 24
Secondary Boom Down Function Inoperative ............................................... 5 - 27
Primary Boom Up Function Inoperative ........................................................ 5 - 29
Primary Boom Down Function Inoperative ................................................... 5 - 31
Primary Boom Extend Function Inoperative ................................................. 5 - 33
Primary Boom Retract Function Inoperative ................................................. 5 - 35
Turntable Rotate Function Inoperative .......................................................... 5 - 36
Turntable Rotate Left Function Inoperative................................................... 5 - 38
Turntable Rotate Right Function Inoperative ................................................ 5 - 39
All Platform Leveling Functions Inoperative .................................................. 5 - 40
Platform Level Up Function Inoperative ........................................................ 5 - 41
Platform Level Down Function Inoperative ................................................... 5 - 42
Genie Z-45/22
Service Manual - First Edition
Part No. 29487