Advertisement
Quick Links
19
8.13
5.07
128.75
2.38
60.45
153.26
.25
6.35
.72
18.26
RUBBER FOOT
1/2" Food Processing
SPFP05 Models
• SPFP05PPT
• SPFP05PPS
• SPFP05PPP
6.03
1610 Satellite Blvd Suite D. Duluth, Ga. 30097 • Phone: (770) 307-1003 • www.standardpump.com
STANDARD PUMP, INC
®
SPFP05
Advertisement
Related Manuals for Standard Pump SPFP05
Summary of Contents for Standard Pump SPFP05
- Page 1 SPFP05 1/2" Food Processing 8.13 5.07 128.75 2.38 SPFP05 Models 60.45 • SPFP05PPT • SPFP05PPS • SPFP05PPP 6.03 153.26 6.35 18.26 RUBBER FOOT STANDARD PUMP, INC ® 1610 Satellite Blvd Suite D. Duluth, Ga. 30097 • Phone: (770) 307-1003 • www.standardpump.com...
- Page 2 Safety Information IMPORTANT WARNING When used for toxic or aggressive fluids, the pump should Read the safety warnings and instructions in this manual always be flushed clean prior to disassembly. before pump installation and start-up. Failure to comply with the recommendations stated in this manual could damage the pump and void factory warranty.
- Page 3 Table of Contents SECTION 1: PUMP SPECIFICATIONS ....1 • Performance • Materials • Dimensional Drawings SECTION 2: INSTALLATION & OPERATION ..4 • Principle of Pump Operation • Typical Installation Guide • Troubleshooting SECTION 3: EXPLODED VIEW ......7 • Composite Drawings •...
- Page 4 Capacity in Liters Per Minute NOTE: Performance based on the following: PTFE fitted pump, flooded suction, water at ambient conditions. The use of other materials and varying hydraulic conditions may result in deviations in excess of 5%. standardpump • Model SPFP05 Food Processing spfp05sm-rev0516...
- Page 5 -20 c to +100 C for model rated as category 2 equipment In addition, the ambient temperature range and the process temperature range do not exceed the operating temperature range of the applied non-metallic parts as listed in the manuals of the pumps . Model SPFP05 Food Processing • standardpump spfp05sm-rev0516...
- Page 6 153.26 6.35 24.96 1.98 O.D. 18.26 18.26 50.29 RUBBER FOOT RUBBER FOOT TRI-CLAMP SUCTION PORT 8.20 208.33 4.49 113.92 4.34 3.15 110.24 80.07 1.19 30.16 RUBBER FOOT 3/8" NPT AIR EXHAUST 5.67 144.08 standardpump • Model SPFP05 Food Processing spfp05sm-rev0516...
- Page 7 (flooded suction condition), pipe the exhaust higher than the product source to prevent siphoning spills . 1" DIAMETER AIR EXHAUST PIPING LIQUID LEVEL SUCTION LINE Model SPFP05 Food Processing • standardpump spfp05sm-rev0516...
- Page 8 To start the pump, slightly open the air shut-off valve. After the pump primes, the air valve can be opened to increase air flow as desired. If opening the valve increases cycling rate, but does not increase the rate of flow, cavitation has occurred. The valve should be closed slightly to obtain the most efficient air flow to pump flow ratio. standardpump • Model SPFP05 Food Processing spfp05sm-rev0516...
- Page 9 Check valve and/or seat is worn or needs adjusting . Inspect check valves and seats for wear and proper setting. Replace if necessary. Entrained air or vapor lock in chamber(s) . Purge chambers through tapped chamber vent plugs . Model SPFP05 Food Processing • standardpump spfp05sm-rev0516...
- Page 10 PTFE 2-PIECE DIAPHRAGM ASSEMBLY 30 in-lbs. Torque Setting: 90 in-lbs. Torque Setting: 90 in-lbs. Torque Setting: 90 in-lbs. Torque Setting: Torque Setting: 70 in-lbs. 60 in-lbs. Torque Setting: Torque Setting: 70 in-lbs. 60 in-lbs. standardpump • Model SPFP05 Food Processing spfp05sm-rev0516...
- Page 11 Suction Manifold 200-354 Manifold Bolts Manifold Washer 200-352 Manifold Nut 200-355 Parts Not Shown (For Rubber Mounting Feet) Qty. Description Part Number Foot, Mounting 200-213 Nut, Hex 200-220 Machine Screw 200-229 Flat Washer 200-245 Model SPFP05 Food Processing • standardpump spfp05sm-rev0516...
- Page 12 Dir produkt voldoet aan de volgende EG-richtlijnen: Denna produkt överensstämmer med följande EU direktiv: Standard Pump, Inc., erklærer herved som fabrikant, at ovennævnte produkt er i overensstemmelse med bestemmelserne i Direkktive: Tämä tuote täyttää seuraavien EC Direktiivien vaatimukstet: Dette produkt oppfyller kravene til følgende EC Direktiver: Este produto está...
- Page 13 Declaration of Conformity Manufacturer: Standard Pump, Inc. 1610 Satellite Blvd., Suite D, Duluth, GA 30097, USA certifies that Air-Operated Double Diaphragm Food Processing and Sanitary Pump Models comply with the European Community Regulation 1935/2004/EC for Food Contact Materials. Food Processing Pump Models:...
Need help?
Do you have a question about the SPFP05 and is the answer not in the manual?
Questions and answers