JAC HFC4181KR1 Owner's Manual page 104

OWNER ' S MANUAL
JAC HEAVY DUTY TRUCK
Ⅳ.Notice during using
1． Notices have to be keep in mind at vehicle driving:
a． Lock the take-up trough;
b． Pull the operation handle in the vehicle rear to agitating position.
2． Notices have to be keep in mind at vehicle operation:
a． Engine should be started for pre-heating at idle before the agitating;
b． Please don't depress the accelerator pedal in the driving cab when the vehicle rear operation is undergoing;
c． Don't get approach to the stuff funnel or agitating tank port, and don't peep inside;
d． Lock the take-up trough;
e． Never pull the handle with a rush in operation;
f． Clean the inner side of agitating tank every time when you finish the working.
3． Notices have to be keep in mind during cleaning and maintenance:
a． When eradicate and wash the concrete on the agitating tank port, rear bracket, support wheel etc, the control level
must in stop position and stop engine at the same time;
b． When performing the repair to agitating tank, support wheel, reducer, hydraulic pump, drive shaft etc, or during oil
filling or changing, the control level must in stop position and stop engine at the same time;
c． Discharging the air from the system while changing the hydraulic oil;
d． Check the oil level after several minutes after fill oil to the reducer, add it if the level decreases.
200
4． Notices have to be keep in mind during eradicate the concrete from the inner of agitating tank:
a． Put the rear control level to neutral position and stop the engine, take the key with the driver to prevent the accident
when the others start the vehicle during the inner agitating tank operation is undergoing;
b． When doing the eradicating, it should be done symmetrical from left and right side step by step to avoid the danger
occurs when the agitating tank turns. If there is much concrete, then let the position with the concrete be just below.
201