Advertisement
MAINTENANCE
4. Drain the petrol from carburettor.
5. Remove the spark plug and feed in several drops of
engine oil through spark plug hole. Crank the engine a
few times and reinstall the spark plug.
6. Remove the battery, store it away from direct sunlight
and freezing temperatures.
7. Place a suitable support at the bottom of the foot board
so that both the tyres are off the ground. This will ensure
better tyre life.
8. Cover up the vehicle completely with a clean tarpaulin or
any other suitable cover. Store the vehicle inside a
garage or similar area to avoid damage due to dust and
rain. Make sure that the storage area is well ventilated
and free from any source of flame or spark.
CAUTION
During storage, the battery must be recharged at recommended
charger if stored more than a month.
TAKING THE VEHICLE OUT OF STORAGE FOR REGULAR
USE
1. Take the vehicle out of garage and clean it thoroughly.
2. Remount the battery after bench charging if required.
3. Fill the engine oil and check the oil level using gauge oil
level.
4. Fill the transmission oil and check the oil level at
inspection screw.
5. Lubricate the parts as instructed in lubrication section.
6. Fill up fresh petrol in the fuel tank.
7. Check and inflate the tyres to the specified tyre pressure.
8. Check and correct the points given in page 27.
9. Turn the ignition switch to 'ON' position. Start the engine
with choke 'ON' for a few minutes and ride out.
CAUTION
Avoid using alkaline solution like detergent soaps for washing. This
may damage head lamp and other lamp assemblies.
RECOMMENDED TIPS WHEN TAKING A LONG TRIP OF
MORE THAN 500 KM:
A) Please keep the following items for use in case of
emergency:
1. Tool kit complete.
2. Recommended spark plug one number.
3. Head lamp & turn signal lamp bulb each one.
4. Throttle, front & rear brake cable each one.
5. First aid kit.
B) Precautions to be taken for the journey:
45
Hide quick links:
Advertisement
