Champion 100269 Operator's Manual
  1. Manuals
  2. Brands
  3. Champion Manuals
  4. Inverter
  5. 100269
  6. Operator's manual

Champion 100269 Operator's Manual

3400w portable inverter generator
Hide thumbs Also See for 100269:
Table of Contents

Advertisement

Quick Links

OPERATOR'S MANUAL
MODEL #100269
3400W PORTAbLE INvERTER GENERATOR
REGISTER YOUR PRODUCT ONLINE
at championpowerequipment.com
or visit championpowerequipment.com
SAvE THESE INSTRUCTIONS. This manual contains important safety precautions which should be read and understood before operating the product. Failure to do
so could result in serious injury. This manual should remain with the product.
Specifications, descriptions and illustrations in this manual are as accurate as known at the time of publication, but are subject to change without notice.
Made in China - REV 20200303
Champion Power Equipment, Inc., Santa Fe Springs, CA USA

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 100269 and is the answer not in the manual?

Questions and answers

Related Manuals for Champion 100269

Summary of Contents for Champion 100269

  • Page 1 This manual should remain with the product. Specifications, descriptions and illustrations in this manual are as accurate as known at the time of publication, but are subject to change without notice. Made in China - REV 20200303 Champion Power Equipment, Inc., Santa Fe Springs, CA USA...
  • Page 2 CARBON MONOXIDE SAFETY: THE BIG PICTURE As the only safe way to use a portable generator, taking your generator outside is absolutely mandatory to keep your family safe from carbon monoxide. But there’s even more you can do. By educating yourself about all carbon monoxide risks, you’ll be better prepared to protect your family from this colorless, oderless threat.

  • Page 3: Table Of Contents

    TAbLE Of CONTENTS 100269 - 3400W PORTAbLE INvERTER GENERATOR TAbLE Of CONTENTS Specifications ..........Generator Specifications ......... Introduction ........... Engine Specifications ..........

  • Page 4: Introduction

    100269 - 3400W PORTAbLE INvERTER GENERATOR INTRODUCTION SAfETY DEfINITIONS Congratulations on your purchase of a Champion Power Equipment The purpose of safety symbols is to attract your attention to possible dangers. The safety symbols, and their explanations, (CPE) product. CPE designs, builds, and supports all of our products to strict specifications and guidelines.

  • Page 5: Important Safety Instructions

    DO NOT use electrical cords that are worn, damaged or frayed. DANGER  Use only Champion electrical cords for proper application. DO NOT operate generator in wet weather. Using a generator indoors CAN KILL YOU IN MINUTES. Generator exhaust contains carbon monoxide. This is a poison DO NOT allow children or unqualified persons to operate or you cannot see or smell.
  • Page 6 IMPORTANT SAfETY INSTRUCTIONS 100269 - 3400W PORTAbLE INvERTER GENERATOR WARNING CAUTION   Spark from removed spark plug wire can result in fire or Start the generator and allow the engine to stabilize before electrical shock. connecting electrical loads. Connect electrical equipment in the off position, and then turn When servicing the generator: them on for operation.

  • Page 7: Fuel Safety

    IMPORTANT SAfETY INSTRUCTIONS 100269 - 3400W PORTAbLE INvERTER GENERATOR fuel Safety When operating the generator: – DO NOT move or tip the generator during operation. DANGER  – DO NOT tip the generator or allow fuel or oil to spill.

  • Page 8: Safety And Dataplate Labels

    EMPLOYEZ UNIQUEMENT DANS UN EMPLACEMENT A L’ABRI DES INTEMPÉRIES - NE PAS EXPOSER À LA PLUIE This artwork belongs to Champion Power Equipment. The contents are confidential and privileged and shall not be disclosed to or used by or for...

  • Page 9: Controls And Features

    CONTROLS AND fEATURES 100269 - 3400W PORTAbLE INvERTER GENERATOR CONTROLS AND fEATURES Read this operator’s manual before operating your generator. Familiarize yourself with the location and function of the controls and features. Save this manual for future reference. Generator 1. Fuel Cap – Remove to add fuel.

  • Page 10: Control Panel

    CONTROLS AND fEATURES 100269 - 3400W PORTAbLE INvERTER GENERATOR Control Panel 1. Fuel Valve Knob – Used to open and close the flow of fuel to RECEPTACLES the engine. 12V DC, 8A 2. Choke – Used to start a cold engine.

  • Page 11: Parts Included

    CONTROLS AND fEATURES 100269 - 3400W PORTAbLE INvERTER GENERATOR Parts Included Accessories Battery Charging Cables ........... Oil Funnel ............RV Adapter Plug ............

  • Page 12: Assembly

    ASSEMbLY 100269 - 3400W PORTAbLE INvERTER GENERATOR ASSEMbLY Your generator requires some assembly. This unit ships from our factory without oil. It must be properly serviced with fuel and oil before operation. If you have any questions regarding the assembly of your generator, call our Technical Support Team at 1-877-338-0999.

  • Page 13: Add Fuel

    ASSEMbLY 100269 - 3400W PORTAbLE INvERTER GENERATOR NOTICE WARNING   The first 5 hours of run time are the break-in period for the Pouring gasoline too fast through the fuel screen may result unit. During the break in period stay at or below 50% of the...

  • Page 14: Operation

    OPERATION 100269 - 3400W PORTAbLE INvERTER GENERATOR – Electrical devices that require a grounded receptacle pin WARNING  connection will not function if the receptacle ground pin is not functional. During operation the muffler and exhaust fumes will become hot. If adequate cooling and breathing space are not supplied,...

  • Page 15: Connecting Electrical Loads

    OPERATION 100269 - 3400W PORTAbLE INvERTER GENERATOR Connecting Electrical Loads 5. Pull choke knob out to the “CHOKE” position. Let the engine stabilize and warm up for a few minutes after starting. Plug in and turn on the desired 120 or 240 (if applicable) Volt AC single phase, 60 Hz electrical loads.

  • Page 16: Eco (Economy) Mode

    OPERATION 100269 - 3400W PORTAbLE INvERTER GENERATOR 12v DC Outlet Power Management Use the following formula to convert voltage and amperage to The 12V DC outlet is ONLY to be used with the supplied 12V DC watts: battery charging cable. The 12V DC output is unregulated and will damage other 12V DC products.

  • Page 17: Parallel Operation

    100269 - 3400W PORTAbLE INvERTER GENERATOR Parallel Operation Operation at High Altitude The Champion model 100269 is parallel ready and can be The density of air at high altitudes is lower than at sea level. operated in parallel with another Champion unit to increase the Engine power is reduced as the air mass and air-fuel ratio total available electrical power.

  • Page 18: Cleaning The Generator

    MAINTENANCE 100269 - 3400W PORTAbLE INvERTER GENERATOR 5. Allow the oil to drain completely into an appropriate container. NOTICE  6. Replace the oil drain bolt. For Emission control devices and systems, read and 7. Replace the rubber maintenance plug.

  • Page 19: Cleaning The Air Filter

    MAINTENANCE 100269 - 3400W PORTAbLE INvERTER GENERATOR Cleaning the Air filter Maintenance Schedule 1. Remove the maintenance cover. Follow the service intervals indicated in the following maintenance schedule. 2. Locate the air filter plastic cover. Service your generator more frequently when operating in adverse 3.

  • Page 20: Storage

    STORAGE 100269 - 3400W PORTAbLE INvERTER GENERATOR STORAGE 6. Option 2: Run Dry 6a. With the generator running, turn the fuel valve to the DANGER  “OFF” position and allow the generator to run until the engine stops from complete fuel starvation. This may Gasoline vapors are highly flammable and extremely explosive.

  • Page 21: Removing From Storage

    STORAGE 100269 - 3400W PORTAbLE INvERTER GENERATOR Removing from Storage If the generator has been improperly stored for a long period of time with gasoline in the gasoline tank and/or carburetor, all fuel must be drained and the carburetor must be thoroughly cleaned.

  • Page 22: Specifications

    SPECIfICATIONS 100269 - 3400W PORTAbLE INvERTER GENERATOR SPECIfICATIONS Recommended Engine Oil Type 10W-30 Generator Specifications 5W-30 10W-40 Generator Model ........... 100269 5W-30 Synthetic Start Type ...........

  • Page 23: Parts Diagram

    SPECIfICATIONS 100269 - 3400W PORTAbLE INvERTER GENERATOR Parts Diagram...

  • Page 24: Parts List

    SPECIfICATIONS 100269 - 3400W PORTAbLE INvERTER GENERATOR Parts List Part Number Description Part Number Description 45 2.13.001 Bushing Ø13.3 x Ø19.3 x 8 Screw/Washer Assembly 1.9074.4.0516.1 46 1.5789.0612.1 Flange Bolt M6 x 12, Black M5 x 16, Black 47 83.200704.02.2 2.08.052.1...
  • Page 25 SPECIfICATIONS 100269 - 3400W PORTAbLE INvERTER GENERATOR Part Number Description Control Unit, 94 83.221000.90.92 3100W/120V/60Hz, Wireless Parallel 95 1.5783.0520 Bolt M5 x 20 96 1.93.05 Lock Washer Ø5 97 122.190600.00 Rectifier Fuel Pipe, Fuel Valve To 98 83.070011.02 Carburetor 99 1.845.4819 Screw ST4.8 x 19...

  • Page 26: Engine Parts Diagram

    SPECIfICATIONS 100269 - 3400W PORTAbLE INvERTER GENERATOR Engine Parts Diagram...

  • Page 27: Engine Parts List

    SPECIfICATIONS 100269 - 3400W PORTAbLE INvERTER GENERATOR Engine Parts List Part Number Description Part Number Description 83.030008.01 Gasket, Crankcase Cover 1.5789.0835 Flange Bolt, M8 x 35 Screw/Washer Assembly, 2.11.014 Oil Seal 1.9074.4.0510 M5 x 10 83.030007.01 Cover, Crankcase 83.080014.01.01 Air Guide Board 83.127000.01...
  • Page 28 SPECIfICATIONS 100269 - 3400W PORTAbLE INvERTER GENERATOR Part Number Description Screw/Washer Assembly, 1.9074.1.0408 M4 x 8 82.132100.00 Base, Stepper Motor 1.819.0508 Screw, M5 x 8 81.130010.00 Spring, Connector 81.130008.00 Connector, Choke Valve Axis 28.131000.03 Carburetor Screw/Washer Assembly, 1.9074.3.0512 M5 x 12 Pressure Plate, Choke Control 81.130007.00...

  • Page 29: Wiring Diagram

    SPECIfICATIONS 100269 - 3400W PORTAbLE INvERTER GENERATOR Wiring Diagram...

  • Page 30: Troubleshooting

    TROUbLESHOOTING 100269 - 3400W PORTAbLE INvERTER GENERATOR TROUbLESHOOTING Problem Cause Solution No fuel. Add fuel. Faulty spark plug. Clean and adjust spark plug or replace. Fill crankcase to the proper level. Low oil level. Place generator on a flat, level surface.

  • Page 31: Warranty

    To complete registration you will need to include a copy of the – Problems caused by parts that are not original Champion purchase receipt as proof of original purchase. Proof of purchase Power Equipment parts.
  • Page 32 AND THE UNITED STATES ENVIRONMENT PROTECTION AGENCY (U.S. EPA) EMISSION CONTROL SYSTEM WARRANTY Your Champion Power Equipment (CPE) engine complies with U.S. EPA emission regulations. YOUR WARRANTY RIGHTS AND OBLIGATIONS: The US EPA AND CPE are pleased to explain the Federal Emission Control Systems Warranty on your 2020 small off-road engine (SORE) and engine powered equipment.
  • Page 33 EMISSION CONTROL SYSTEM WARRANTY The following are specific provisions relative to your Emission Control System (ECS) Warranty Coverage. 1. APPLICABILITY: This warranty shall apply to 1997 and later model year small off-road engines (SORE). The ECS Warranty Period shall begin on the date the new engine or equipment is delivered to its original, end-use purchaser, and shall continue for 24 consecutive months thereafter.
  • Page 34 You must take your CPE engine or the product on which it is installed, along with your warranty registration card or other proof of original purchase date, at your expense, to any Champion Power Equipment dealer who is authorized by Champion Power Equipment, Inc. to sell and service that CPE product during his normal business hours.

Table of Contents