Download Print this page

Element4 Tenore 100 GSB Installation, Operation And Owner's Manual

Direct vent gas fireplaces
Hide thumbs Also See for Tenore 100 GSB:

Advertisement

Quick Links

HOT GLASS WILL
CAUSE BURNS.
DO NOT TOUCH GLASS
UNTIL COOLED.
NEVER ALLOW CHILDREN
TO TOUCH GLASS.
A barrier designed to reduce the risk of burns from the hot viewing glass is provided with this appliance and shall be installed
for the protection of children and other at-risk individuals.
Une barrière conçu pour réduire le risque de brûlure par le verre de visualisation chaude est fournie avec cet appareil et doit
être installé pour la protection des enfants et autres personnes à risque.
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could
result in serious injury, death, or property damage.
- Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
- WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not
use any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier from a
neighbor's phone. Follow the gas supplier's
instructions.
• If you cannot reach your gas supplier, call
the fire department.
- Installation and service must be performed
by a qualified installer, service agency or the
gas supplier.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
Element4 Gas Fireplaces Rev #05112020
Installation, Operation and Owner's Manual
Tenore 100
Lucius 100
Direct Vent Gas Fireplaces
AVERTISSEMENT:
INCENDIE OU D'EXPLOSION
Le non-respect des avertissements de sécurité à la
lettre pourrait entraîner de graves blessures , la mort
ou des dommages matériels.
- Ne pas entreposer ni utilizer d'essence ni d'autres vapeurs
ou liquides inflammables dans le voisinage de cet appareil
ou de tout autre appareil.
- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ
• Ne pas tenter d'allumer d'appareil.
• Ne touchez á aucan interrupteur. Ne pas vous servir des
téléphones se trouvant dans le bátiment ou vous trouvez.
• Quitter immédiatement le bâtiment.
• Appelez immédiatment votre fournisseur de gaz depuis
un voisin. Suivez les instructions du fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz
appelez le service des incindies.
- Installation et l'entretien doivent être effectués par un
installateur qualifié, une agence de service ou le fournisseur
de gaz.
INSTALLATEUR: Laissez cette notice avec l'appareil.
CONSOMMATEUR: Conservez cette notice pour
consultation ultérieure.
1
4006611
GSB
GSB
Une surface vitrée chaude
peut causer des brûlures.
Laisser refroidir la surface
vitrée avant d'y toucher.
Ne permettez jamais á un enfant
de toucher la surface vitrée.
EuropeanHome.com
May 2020

Advertisement

loading
Need help?

Need help?

Do you have a question about the Tenore 100 GSB and is the answer not in the manual?

Questions and answers

Summary of Contents for Element4 Tenore 100 GSB

  • Page 1 INSTALLER: Leave this manual with the appliance. INSTALLATEUR: Laissez cette notice avec l’appareil. CONSUMER: Retain this manual for future reference. CONSOMMATEUR: Conservez cette notice pour consultation ultérieure. May 2020 EuropeanHome.com Element4 Gas Fireplaces Rev #05112020 4006611...
  • Page 2: Table Of Contents

    TABLE OF CONTENTS Important Safety Information ..................... 3 Key Installation Points ......................6 Planning Your Gas Fireplace....................7 User Information ........................9 Specifications & Dimensions....................10 Lucius 100 GSB Parts of the Fireplace Clearances ..........................14 Locating the Fireplace Placing the Fireplace Clearances to Combustibles Clearances to Non-Combustibles Mantel Clearances...
  • Page 3: Important Safety Information

    Do not place furniture or other objects within 36” of the fireplace glass. SAVE THESE INSTRUCTIONS Make yourself fully aware of all the following instructions and the many features of the Element4 direct vent gas fireplace appliance. INSTALLER: Leave this manual with the appliance.
  • Page 4 : Glass Handling jurisdiction for gas product installations to determine their specific requirements for high altitude installations. The glass must only be removed by a qualified person. Gloves should be worn when removing the glass. Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 5 DO NOT USE abrasive cleaners on the panels. DO NOT the nearest 1/16” when converted. If greater accuracy is ATTEMPT to clean the glass panels when they are hot. required, use the metric dimensions. Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 6: Key Installation Points

    Gas pressures MUST be read with a manometer and confirmed with what is required in the installation manual. FINISHING 1/8” gap between the flange and the enclosing wallboard MUST be maintained to prevent cracking from heat expansion and contraction. Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 7: Planning Your Gas Fireplace

    PLANNING YOUR GAS FIREPLACE Before You Begin Since the Element4 fireplaces are vented gas appliances they must be installed by a qualified installer. • Your sales representative can help you choose the appropriate professional. Overall Design • One of the many features of the Element4 fireplace is its use of convective air flow.
  • Page 8 If the venting falls outside of the vent graphs, a power vent is available. • The next question to ask is, “Can I get my gas pipe to the fireplace?” The Element4 fireplaces burn either Important Points natural gas (NG) or propane gas (LP.) Your sales representative will ask you for your requirement at the •...
  • Page 9: User Information

    WARMTH AND BEAUTY - HOW IT WORKS This Element4 fireplace is a direct vent fireplace and, as such, the intake and exhaust air moves through the vent pipe. To lower the temperature of the glass panel(s), the fireplace has a Glass Safety Barrier between the room and the inner panels(s). This Glass Safety Barrier includes fans to move room air between the two layers of viewing glass thus providing warm air to the room.
  • Page 10: Specifications & Dimensions

    Efficiency 78.3% A sample listing label image is shown above. A metal listing label is attached Figure 2 to every Element4 fireplace and contains important certification information. The listing label must not be removed from the fireplace. CAD FILES A DWG/DXF file is available for download at www.europeanhome.com for dimensions not shown.
  • Page 11 10A @ 104°F Cord Length 6 Feet Agency Approvals Figure 6 Fan Set A Fan Set B Snap Switch Speed Control Fan Set C Fan Set D Fan Set E Fan Set Electrical Schematic Figure 7 Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 12: Lucius 100 Gsb

    This information is for reference only. Please consult the Installation Manual for all details prior to making any design decisions. Conversions from millimeters are rounded to the nearest fraction. A DWG file is available at www.europeanhome.com PDE4L100GSB-170807 This information is for reference only. Please cons Conversions from millimeters are rounded to the Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 13: Parts Of The Fireplace

    Inner Glass Clamps - holds the Inner Glass Panels in place Vent Collar - accepts the 5” x 8” venting adapter (included) Relief Door - part of the safety system. Do NOT block the operation of the relief doors. Pilot Assembly Figure 11 Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 14: Clearances

    YOUR RESPONSIBILITY TO ENSURE THE SAFETY OF THESE CRITICAL COMPONENTS THROUGHOUT THE INSTALLATION CRITICAL COMPONENTS THROUGHOUT THE INSTALLATION PROCESS. REMOVE AND DISPOSE OF ALL WRAPS AND TIES. PROCESS. REMOVE AND DISPOSE OF ALL WRAPS AND TIES. Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 15: Clearances To Combustibles

    We recommend that the fireplace be set into its final location before building the enclosure. Please refer to the “Reduced Clearance to Existing Combustible Wall” section for use of combustibles inside of the above clearances. Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 16: Mantel Clearances

    (TYPICAL) Mantel Depth NON COMBUSTIBLE 12” (300 MATERIAL CONSTRUCTION BEAMS NON- COMBUSTIBLE (TYPICAL) DETAIL C ETAIL C 1”/25 mm ALE 1 : 10 TOP OF FIREPLACE OPENING GLASS CONVECTION GAP Figure 15 Figure 16 Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 17: Opening Clearances

    72” Room ceiling to Square Square Square Square 1830 appliance bottom Model Inches Centimeters Inches Centimeters 1” Chase ceiling to top of Air Outlet Tenore 100 GSB Lucius 100I GSB Figure 18 Figure 19 Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 18: Gas And Electric

    The cooling fans are powered by 120V AC and connect to the dedicated duplex receptacle via the provided six foot long power cord. Electrical work must be performed by a qualified, licensed electrician. WARNING All wiring shall be in compliance with all local, city, and state codes. Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 19: Venting

    Pro-Form (BDM - Bernard Dalsin Manufacturing) Direct-Temp (Selkirk Corporation) AmeriVent Direct Vent (Hart & Cooley Inc.) Ventis Direct Vent (Olympia Chimney Supply, Inc.) Figure 21 Please visit www.europeanhome.com/technical-support/ for the power venting installation manuals Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 20 Calculate the Total Vertical Section by adding up all vertical upward sections in your vent design. CALCULATING THE TOTAL HORIZONTAL SECTION (THS) Calculate the Total Horizontal Section by adding up all horizontal sections in your vent design. Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 21 Loosen the screws on either side and slide the restrictor as desired. Do not modify the restrictor. Please use the following graph to determine if you will need to use a restrictor. Loosen these two Phillips head screws to slide the restrictor on/off. Figure 28 Figure 27 Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 22: Venting Charts

    5' (1.5 m) 6'-7" (2 m) 8'-3" (2.5 m) 9'-10" (3 m) 11'-6" (3.5 m) 13'-2" (4 m) Figure 30 configuration allowed, no restrictor required configuration allowed, 35mm restrictor required configuration NOT allowed Figure 31 ents Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 23: Termination Clearances

    VENTING CLEARANCES HORIZONTAL VENT TERMINATION CLEARANCES AND REQUIREMENTS Figure 32 Figure 33 Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 24 National Fuel Gas Code (ANSI Z223.1 in the USA) or the current standard of CAN/CSA-B149.1 in Canada. Figure 34 Figure 35: Termination Heights A second termination may be no closer than 12”/305 Figure 36: Multiple Termination Clearance Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 25: Enclosing The Fireplace

    Figure 37: * The listed brand names are trademarks of their respective companies. Skamol Americas, Inc. (844) 475-2665 E-mail: skamotec225@skamol.com www.skamotec225.com Promat Inc. (865) 681-0155 E-mail: sales@promat.us www.promat.us/en James Hardie Building Products (888) 542-7343 www.jameshardie.com Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 26 Most important, these fireplaces are NOT zero-clearance fireplaces. Unlike zero-clearance fireplaces, there is not a metal box around the Element4 fireplaces. With no metal box there are no louvers to distract your view of the fire. However, we want the cooling advantage of a metal box so your site-built, non-combustible enclosure will substitute.
  • Page 27 1” (25 1” (25 Minimum Air Gap MUST BE MAINTAINED Minimum Air Gap MUST BE MAINTAINED Figure 38 Combustible Wall Shield Over Finished Wall Shield Over Finished Wall Combustible Wall Figure 40 Figure 41 Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 28 1/2” (12 James Hardie Building Products HardieBacker® 500 1/2” Cement Board 1/2” (12 James Hardie Building Products HardieBacker® 1/4” Cement Board 1/4” (6 Figure 42 Figure 44 Figure 43 Minimum Wall Thickness = 1/2” (12 Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 29 Minimum Required Air Opening Sizes Air Inlet Air Outlet Square Square Square Square Model Inches Centimeters Inches Centimeters Lucius 100 GSB Figure 47 Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 30 Figure 48 Tenore 100 GSB shown. The Lucius 100 GSB model have the same requirement. Use the adjustable feet to ensure that the fireplace is level prior to enclosing it. Do NOT lift the fireplace by the face frame but by the bottom of the cabinet.
  • Page 31: Cold Climate Installation

    23” 44” the cabinet edge than shown at left. 1117 The drawing is not to scale. Figure 50 48” 1219 ENSURE THAT ALL WIRING AND CABLES ARE CLEAR OF ALL OF THE FANS! Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 32 The fans will turn off when the Shutoff Snap Switch reaches its set point and subsequent start attempts are not possible until the 2 thermocouple cools down. Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 33: Installing The Fire Media

    - two bags of black chips - one bag of grey chips With the embers scattered across the burner and hearth panel, lay the logs in the following sequence... Figure 52 Figure 53 Figure 54 Figure 55 Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 34 (Figure __) clear of media (Figure __). 2nd Thermocouple 2nd Thermocouple Pilot Assembly Pilot Assembly Figure 57 To see how to arrange media in an Element4 fireplace please visit the link below. WWW.EUROPEANHOME.COM/RESOURCES/VIDEOS/ Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 35: Operating The Fireplace

    ON when the fireplace is Figure 59 turned on. Note! For normal operation the MANUAL knob on the gas valve cannot be in the MAN position; it must be fully in the ON position. Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 36 OPERATING the FIREPLACE OPERATING the FIREPLACE Figure 60 Figure 62 Figure 61 Figure 63 Element4 Gas Fireplaces EuropeanHome.com Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 37 OPERATING the FIREPLACE OPERATING the FIREPLACE Figure 64 Figure 65 Figure 66 Figure 67 Figure 68 Figure 70 Figure 69 Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com Element4 Gas Fireplaces EuropeanHome.com...
  • Page 38 OPERATING the FIREPLACE OPERATING the FIREPLACE Figure 71 Figure 72 Figure 74 Figure 73 Figure 75 Figure 76 Figure 77 Figure 79 Figure 78 Element4 Gas Fireplaces EuropeanHome.com Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 39 OPERATING the FIREPLACE OPERATING the FIREPLACE Figure 80 Figure 81 Figure 82 Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com Element4 Gas Fireplaces EuropeanHome.com...
  • Page 40 • CHILD PROOF (To activate press buttons simultaneously. displayed and the handset is rendered inoperable (except for off functi- on). • PROGRAM MODE • THERMOSTATIC MODE (also deactivates Program Mode) • ECO MODE • MULTI-BURNER FEATURE • COUNTDOWN TIMER Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 41 The premium materials and build quality of your fireplace will keep these sounds to a minimum. FAN OPERATION The fans are powered by a dedicated 120V AC and work automatically. A sensor on top of the fireplace frame turns on the fans Figure 84 Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 42: Maintenance

    Inner Glass Panels in place. Unscrew the retaining bolt(s) holding the glass clamp and then remove the clamp. Remove all of the retaining Figure 87 bolts and clamps holding Inner Glass Panels. Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 43 Repeat for the other long panel (if equipped). Step 9. Lift the short Outer Glass Panel up into its clearance notch and swing the lower edge of the glass in, and down, into the channel. Figure 89 Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 44: Burner

    The pilot has two distinct flames, one engulfing the thermocouple on its left, the other reaching across to the burner. The area around the pilot should be inspected for cleanliness. Lint or foreign material must be removed with a brush or vacuum. Figure 90 Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 45: Thermocouple

    MAINTENANCE THERMOCOUPLE MAINTENANCE The Element4 fireplaces have two thermocouples; one next to the pilot and one opposite the pilot side of the burner. The completeness and operation of both must be checked. A qualified installer must confirm that both thermocouples are in place and not damaged.
  • Page 46: Replacement Parts

    E4-GS-CM-Wifi-03 Befor 1/2020 (Control Module) E4-GS-CM-Wifi-04 After 1/2020 Main Burner Second Burner Piolot Assembly E4PGS-PABT-01 Second Thermocouple E4-GS-2TC-01 6 Volt Adaptor AC Adaptor-03 Wifi-Box (Optional) E4-GS-Con-Wifi-01 10 Button Remote Repl-E4-GS-RC-10B Figure 94 Figure 95 Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 47: Warranty

    Installer: Please complete this form. Customer: Please retain this information. Model Lucius 100 GSB Tenore 100 GSB Purchased From Date of Purchase Installed By Date of Installation Fireplace Serial Number Fuel Type Total Venting Horizontal Total Venting Vertical Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 48: Massachusetts Certification

    Gas Fitters has issued approval number G3-0116-219 for this appliance. The following must be observed when installing the Element4 fireplaces within the Commonwealth of Massachusetts: (a) For all side wall horizontally vented gas fueled equipment installed in every dwelling, building or structure used in whole...
  • Page 49: Troubleshooting Flowchart

    Motor not operating Replace gas valve. properly. Micro switch not Replace gas valve. operating properly. 2nd thermocouple Confirm integrity of 2nd thermocouple and not connected connection. (continued) EuropeanHome.com Element4 Gas Fireplaces Rev #05112020 I:\DEPARTMENTS\Technical Support\Troubleshooting\Guides\20181205_Troubleshooting Flow Chart_E4_8btn Edition.indd...
  • Page 50 Short between interrupter block and TC- Check connection to interrupter block. cable. Sparking stops after pilot is lit. Electronic measuring amplifier defective. Replace the receiver. (continued) EuropeanHome.com Element4 Gas Fireplaces Rev #05112020...
  • Page 51 Turn the control knob to “ON” position, a Manual knob is in the “MAN” position. positive latch is required. Main burner is lit. Confirm correct gas pressure. Increase pilot Pilot flame is too low. flame if necessary. (continued) EuropeanHome.com Element4 Gas Fireplaces Rev #05112020...
  • Page 52 The valve will turn to pilot flame if the set temperature and the ambient temperature remain the same over a 6 hour period. (continued) EuropeanHome.com Element4 Gas Fireplaces Rev #05112020...
  • Page 53 Check venting for complete integrity. Reduce the primary air opening until flames have blue Too much primary air. base and yellow upper two-thirds. Flames are stable but too small and blue. NORMAL OPERATION EuropeanHome.com Element4 Gas Fireplaces Rev #05112020...
  • Page 54: Connecting To A Smart Home System

    Frequent ON and OFF cycles will limit life expectancy of the valve and will increase battery consumption. The fireplace should be powered by the AC adapter for improved reliability and customer satisfaction. EuropeanHome.com Element4 Gas Fireplaces Rev #05112020...
  • Page 55 No communication between receiver and Wi-Fi Contact service No control possible by the electronics module Contact service No temperature display in the App • No remote control connected “N.a. ” in the App • Batteries in remote control empty EuropeanHome.com Element4 Gas Fireplaces Rev #05112020...
  • Page 56 2x 1.5 V AAA 4 sec. No reaction from the fireplace No or bad connection between the receiver and Interrupted responses remote control No electronic control No voltage on the receiver Low communication range, AC adapter EuropeanHome.com Element4 Gas Fireplaces Rev #05112020...
  • Page 57 Try to keep jammers as far away as possible devices can not connect via the 5GHz band, the ProControl from the router. Neighboring wireless networks also play a module is not suitable for 5GHz band. role in the Wi-Fi area. EuropeanHome.com Element4 Gas Fireplaces Rev #05112020...
  • Page 58 Learances Lp 45 onverting to nstaLLing the ressures WALL ACCESS DOOR 31 WARRANTY 47 KEY INSTALLATION pOINTS 6 LISTING LABEL 10 Lp (p ROpANE ONvERSION MAINTENANCE urner Lass iLot herMocoupLes enting MANTELS 16 Element4 Gas Fireplaces Rev #05112020 EuropeanHome.com...
  • Page 59 NOTES EuropeanHome.com Element4 Gas Fireplaces Rev #05112020...
  • Page 60 Imported and distributed in North America by: EUROPEAN HOME a division of Europa Ja, Inc. 30 Log Bridge Road Building 300 - Suite 303 Middleton, MA 01949 www.europeanhome.com IGE45IIG-180328 EuropeanHome.com Element4 Gas Fireplaces Rev #05112020...

This manual is also suitable for:

Lucius 100 gsb