Engine Oil - Ford F-MAX User Manual

Do not fi ll the urea tank with any material
other than urea.
Fill the tank with urea complying with DIN
70070 / ISO 22241-1 standard only.
• Do not fi ll the tank with diesel fuel.
• Do not add water to the tank to increase
urea level.
Quality of the fuel and engine oil used
a ects Urea system.
a-) Sulphur Content in the Fuel
Low quality fuel contains high sulfur ratio.
Sulphur may cause blockage of catalyst, a
component of the urea system. You should
use EuroDiesel only in your vehicle.
b-) Engine Oil
Low quality and/or wrong viscosity oil
increases the oil vapor in the exhaust. This
may cause blockage of the catalyst.
MAINTENANCE AND SERVICE
Catalyst is a non-serviceable component
that cannot be cleaned.
Exhaust box shall be replaced as a whole
when it is blocked. Pay attention to the
quality of the urea, fuel and engine oil
used and apply all instructions about
urea system with care in order to avoid
damages with high costs.
If the exhaust temperature is consistently
low (buses, delivery trucks), effi ciency
of Urea system may be reduced and
ammonia may come out.
Contact your workshop if you continuously
smell ammonia.
User shall carry out following
precautions to prevent faults and
damages in this system. Otherwise any
faults occurring should be considered
outside of the warranty cover and Ford
Otosan will not take any responsibilities!
You shall comply with the
regulations for preventing the
accidents!
- 163 -
Urea System
WARNING
Exhaust gas reaches very high
temperatures during regeneration or
while operating under high load. "HES"
light shall be illuminated on the
warning panel of your vehicle in high
exhaust gas temperatures.
Switching off your vehicle while this light
is illuminated may cause damage to
urea system components.
* Average urea consumption values
depend on the test results of the vehicle
and the dynamometer.
These values may vary for reasons such
as vehicle's load condition, environmental
factors (ambient temperature, air
pressure, relative humidity), engine
coolant temperature and urea quality.
5