Page 1
Maintenance and Repair Parts Manual Engine Powered Gasoline/Diesel Battery Electric P/N 12431B December 2005...
Page 2
Dealer rental fleet, whichever comes first. Any part or parts which, upon examination by the Snorkel Service Department, are found to be defective, will be replaced or repaired, at the sole discretion of Snorkel, through its local Authorized Dealer at no charge.
Table of Contents Table of Contents Section A. - General Specifications Section B. - Maintenance Information General Specifications ......i About this Manual:.
Section A. - General Specifications The Snorkel MHP13/35 is a boom supported elevating work platform built to conform to these standards, American Standard ANSI A92.2-2001 Canadian Standard C225-00 2002 Australian Standard AS1418-10(Int) 2004 Elevating Work Platforms. General Specifications SPECIFICATIONS MHP13/35 12.6m...
General Specifications Engine Specifications Engine Make Honda (gas o line) Model GX 160 Engine type 4-stroke, over head valve, 1 cylinder Displacement 163 cm (9.9 cu-in) Bore x Stroke 68 x 45 mm (2.7 x 1.8 in) Max. output 4 kW/4,000 rpm Max.
Electrical (Section 3), contains listings and current production machines only. drawings of electrical components installations including wiring schematics. While Snorkel has attempted in every way to confirm that all information in this manual is correct, Options improvements are being constantly made to the machine that may not be reflected in this manual.
- blocked or the weight removed by a suitable lifting device before disconnecting the Maintenance schedules hydraulic hose from the motor/pump unit to the lift Snorkel has established a Preventive Maintenance cylinder. Schedule that includes: When raising a portion of the machine, be sure that Daily Maintenance (Operator’s Inspection)
Maintenance Information 90 Day or 150 Hour Maintenance (Trained Service Technician) Components Service Required Recommended Lubricant or Further Instructions Daily maintenance Perform maintenance as per schedule Preventive inspection Perform inspection, complete form Retain copy of checklist maintenance checklist Placards and decals inspection Inspect using drawing and parts listing Replace any missing or in section 1 (repair parts)
This drawing locates the lubrication points of the MHP13/35. Lubricants Engines Specific lubricants as recommended by Snorkel, should be used in maintaining your unit. If in doubt Engine. Refer to the engine manufacturer’s regarding the use of lubricants other than those instruction manual or consult your local engine listed, contact Snorkel.
Maintenance Information If questions still remain, contact Snorkel for further DANGER information. Lead-acid batteries contain sulfuric acid Return filter which will damage eyes or skin on contact. When working around batteries, ALWAYS Return filter. On MHP13/35 models, the hydraulic oil wear a face shield to avoid acid in eyes.
Maintenance Information Preventive inspection maintenance 90 day or 150 hour checklist OK OK - No Service Required Serial Number Corrective Action Required Corrected, (Record description of corrective action). Check Inspection Procedures Codes Platform rotator (Optional) (3,4) (1) Weld cracks, dents and/or rust Platform rotation holding valve (3,4) (2) Installation Rotator mounting bolts (2,6)
Page 18
Maintenance Information Corrective Action Required Note: If correction action is required on any item, attach sheet indicating problem and action taken. All items have been properly checked and tested and found to be operating satisfactory or necessary corrective action has been completed. Inspected By: Date page xii...
Maintenance Information To order service or repair parts Manuals When placing an order for service or repair parts, Manuals are available from Snorkel to support any please have the following information available for of the machines that we produce. your machine.
Weight to the platform. 9. Raise the booms to maximum outreach Equipment (lower boom fully up and top boom and jib MHP 13/35 boomhorizontal). The “Test load” must be between 100 and 200mm above ground. Spirit level 10. Attach a ratchet tie down to the rope coming Rope from pulley.
Page 22
Maintenance Information Figure 1 ROPE CHAIN 70.1 M +W 7000 RATED LOAD R = 239kg MANUAL FORCE M = 44.8kg STANDARD MACHINE WIND FORCE W = 25.3kg = 217kg WITH ROTATOR LOAD ON PULLEY = 70.1kg page xvi MHP13/35 – 12431B...
Column assembly before SN NZ050901 Column assembly before SN NZ050901 Item Part No Description 12381A Column assembly 1034-120 Hardened washer 1067 Slew ring 1288 Battery 1814 Cable gland 11942 Slew pinionr 3605-05 Plain washer 3603-06 Plain washer 60030-197 Plain washer 12377A Main control manifold 3603-12...
Column assembly before SN NZ050901 Item Part No Description 12483-4 Tube 12483-3 Connector 12483-2 Adaptor page 1 - 14 MHP13/35 – 12431B...
Page 37
Column assembly drawing before SN NZ050901 HYDRAULIC OIL TANK ASSEMBLY (See Hydraulics Section) MAIN CONTROL MANIFOLD (See Hydraulics Section) ENGINE ASSEMBLY (See Repair Parts Section) TITLE Column assembly Page 1-15 Revision A June 15 2005 DWG. 12381A Snorkel Model MHP13/35...
Page 38
HYDRAULIC OIL TANK ASSEMBLY Column assembly drawing after SN NZ050901 (See Hydraulics Section) MAIN CONTROL MANIFOLD (See Hydraulics Section) ENGINE ASSEMBLY (See Repair Parts Section) TITLE Column assembly DWG. 12381A Page 1-16 Snorkel Model MHP13/35...
Column assembly after SN NZ050901 Column assembly after SN NZ050901 Item Part No Description 12381A Column assembly 1034-120 Hardened washer 1067 Slew ring 1288 Battery 1814 Cable gland 11942 Slew pinionr 3605-05 Plain washer 3603-06 Plain washer 60030-197 Plain washer 12377A Main control manifold 3603-12...
Page 40
Column assembly after SN NZ050901 Item Part No Description 12483-4 Tube 12483-3 Connector 12483-2 Adaptor 12381-40 Heat deflector 9990 Thrust washer page 1 - 18 MHP13/35 – 12431B...
Tow coupling hydraulic Tow coupling hydraulic Item Part No Description 11572 Coupling assembly, TC40HM/50mm 11572-1 Body 11572-2 Main shaft and head assembly 9946-15 Main shaft spring 9946-13 Reverse lock 9946-14 Thrust ring 9946-17 Collar 60015-017 Grub screw 1 ¼” x ¼” BSW 2030-001 Grease nipple Refer item 2...
Section 2. - Hydraulics Section 2 Hydraulic schematic drawing for standard units . . . 2-3 Hydraulic schematic drawing for units fitted with self level stabilisers ..2-4 Main control valve ......2-4 Upper lift cylinder assembly .
Page 59
CONTROL VALVE VALVE VALVE TANK STABILISER ACCUM TANK AUX. PORT PORT PORT MOTOR PUMP AUX. MOTOR OPTION RETURN FILTER 10 MICRON LEG 4 TITLE Hydraulic schematic for LEG VALVE BANK 11921 standard machines DWG. 0000000 Snorkel model MHP13/35 Page 2-3...
Page 60
TANK STABILISER ACCUM TANK AUX. PORT PORT PORT MOTOR PUMP AUX. MOTOR OPTION RETURN FILTER 10 MICRON LEG 4 LEG VALVE BANK 11921 TITLE Hydraulic schematic for units fitted with self level stabilisers Page 2-4 Snorkel model MHP13/35 DWG. 0000000...
Main control valve Main control valve Item Part No Description 12377A Main control valve assembly 11415-1 Stabiliser solenoid 11415-2 Flow compensator 11415-3 Main relief valve 2500 psi 11415-4 Solenoid emergency lower 11415-5 Manual emergency lower 11415-6 Check valve 4 psi 11415-7 Proportional flow control 11415-8...
Stabiliser leg cylinder assembly Stabiliser leg cylinder assembly Item Part No Description 12336A Stabiliser leg cylinder assembly 12336 Stabiliser leg cylinder 12336K Seal kit 3603-06 Plain washer 3663-04025 Hex head socket cap screw 3605-06 Spring washer 3610-06012 Metric bolt 3610-06020 Metric bolt 3611-04 Metric Nylock nut...
Hydraulic oil tank assembly Hydraulic oil tank assembly Item Part No Description 14430A Hydraulic oil tank assembly 3603-06 Plain washer 3605-06 Spring washer 3611-06 Metric Nylock nut 3613-06030 Metric cap screw 7013-002 BSPP (Dowty) x JICM nipple 7034-004 0.5" BSPTM plug 11430-7 Suction pipe weldment (Replaces plug for electric motor option) 11430-10...
P/N 1650-010 (A1 - A12) and (B1 - B12) REPRESENT TERMINALS R3 = STABILISER RELAY P/N 1650-010 ON TERMINAL STRIP IN THE LOWER CONTROL BOX TITLE Electrical Schematic for standard machines Page 3-3 Revision B 05-07-2005 DWG. 11406-2 Snorkel model MHP13/35...
Page 74
Electrical schematic, Auto stabiliser Page 3-4...
Automatic stabiliser control box assembly before SN NZ051001 Automatic stabiliser control box assembly before SN NZ051001 Item Part No Description 12404A Control box assembly, auto stabiliser 12404 Control box 560377 Lamp, 12V green (before Serial number NZ050901) 12536-3 LED, 12V green (from Serial number NZ050901) 3604-05020 Pan head screw 302-0016...
Automatic stabiliser control box assembly after SN NZ051001 Automatic stabiliser control box assembly after SN NZ051001 Item Part No Description 12404A Control box assembly, auto stabiliser 12404 Control box 12536-3 LED, 12V green (from Serial number NZ050901) 3604-05020 Pan head screw 302-0016 Switch, toggle, SPDT (M/OFF/M) 12416...
Upper control box assembly Upper control box assembly Item Part No Description 12385A Upper control box assembly 8808-1 Start switch 3 position 9776 Collar and contact block 9775 Stop switch head 560377 Lamp, 12V, green (before serial number NZ051001) 12385A LED, 12V, green (from serial number NZ051001) 304-0412 Rheostat...
Lower control box assembly before SN NZ050901 Lower control box assembly before SN NZ050901 Item Part No Description 11406-1 Control box, lower, drilled 11420 Decal, control box 302-0013 Switch, toggle DPDT (ON/ON) 302-0015 Switch, toggle SPST (MOM/OFF) 302-0018 Switch, toggle DPDT (M/OFF/M) 302-0048 Switch, toggle 4PDT (ON/ON) 3020087...
Lower control box assembly from SN NZ050901 Lower control box assembly from SN NZ050901 Item Part No Description 12521 Control box, lower 56368-6 Circuit breaker, 15 amp 304-0438 Knob, speed control switch 1814 Cable gland (not shown) 1815 Cable gland (not shown) 9775 Stop switch head 10744...
AC motor option drawing AC motor option drawing HONDA STARTER (terminal 85) SOLENOID CONTACTOR RELAY NEUTRAL PHASE LINE AC MOTOR SWITCH LOAD EARTH To B12 MOTOR To A8 12v.DC POWER SUPPLY page 3 - 12 MHP13/35 – 12431B...
AC motor option with 240VAC outlet drawing AC motor option with 240VAC outlet drawing HONDA STARTER (terminal 85) SOLENOID SOCKET OUTLET CONTACTOR RELAY NEUTRAL PHASE LINE AC MOTOR SWITCH LOAD EARTH To B12 MOTOR To A8 12v.DC POWER SUPPLY MHP13/35 – 12431B page 3 - 13...
240V AC MOTOR ASSEMBLY (See Options Section) MOTOR ASSEMBLY (See Repair Parts Section) POWER SUPPLY UNIT TRAILER ASSEMBLY ELECTRIC MOTOR SUPPLY BOX (See Repair Parts Section) (See Options Section) TITLE Honda 240V Gas/AC Option Page 4-11 DWG. Snorkel Model MHP13/35...
Electric motor supply box Electric motor supply box Item Part No Description 12486 Electric motor supply box 1815 Compression gland 1865-001 Switch 2500-5 Relay 2500-6 Relay mounting base 10967-1 10967-2 Appliance inlet 10967-4 Enclosure lid 10967-6 Enclosure 11588 Relay MHP13/35 – 12431B page 4 - 13...
240 AC motor 240 AC motor Item Part No Description 1867-001 240V AC electric motor 1657-007 Coupling taper shaft 3612-06010 Grub screw 1658-006 Bell housing 11432 Pump 7013-004 BSPP x JICM nipple 3605-06 Spring washer 3610-06025 Bolt 6983-001 JIC F tapped hole plug 7013-003 BSPP x JICM nipple 9501-2...
240V AC basket outlet 240V AC basket outlet Item Part No Description 12485-2 240V AC basket outlet 1807 Appliance outlet 1865-001 Switch 10263 Compression gland 10967-3 Switch enclosure 10967-5 Mounting feet 3611-05 Nylock nut 3603-05 Plain washer 3610-05010 Bolt page 4 - 16 MHP13/35 –...
Page 101
240V AC basket outlet drawing Basket Assembly ATTACHMENT DETAIL ATTACHMENT POSITION 240V AC BASKET OUTLET TITLE 240V AC Basket Outlet Page 4-17 DWG. Snorkel Model MHP13/35...
Ground power supply option drawing ATTACHMENT POSITION ATTACHMENT DETAIL GROUND POWER SUPPLY TITLE Ground Power Supply Page 4-18 Snorkel Model MHP13/35 DWG.
Parts index - Page location Standards American standard, A-i Australian standard, A-i Canadian standard, A-i Tow coupling assembly, 1-30 Trailer assembly, 1-3 Upper control box assembly, 3-9 Upper lift cylinder assembly, 2-5 Warranty - Limited See inside front cover Working envelope, A-iii index 2 MHP13/35 –...
Need help?
Do you have a question about the MHP 13/35 and is the answer not in the manual?
Questions and answers