Regulations To Be Followed During Operation; Maintenance Regulations; Maintenance; Engine - RCm MONO BOXER D Instruction And Maintenance Handbook

ENGLISH

REGULATIONS TO BE FOLLOWED DURING OPERATION

Never sweep up ropes, wire, straps, water, etc.
To pick up large but light objects (such as paper, leaves, etc.), push down on the pedal 2 (fi g.1) to raise the
front fl ap of the machine slightly for just the time necessary to sweep the objects up.
Shake the fi lters from time to time by the swicht 14 (Fig. 1) to position B.
If the ground to be swept is wet, shut off the vacuum fan using the switch 14 on position N (Fig. 1), as othe-
rwise the suction fi lter may be clogged.
Never pick up glowing cigarette ends or red hot material.
In presence of a lot of dust it is need to execute a fi rst phase of cleaning using the main brush only. Do not
allow outsiders to approach the machine, especially children.
The machine must only be used by operators authorised by the person in charge of the machine, who are
familiar with the contents of this manual. These operators must be physically and mentally suitable, and
must not be under the infl uence of alcohol, drugs or medication.
Make sure that:
- there are no foreign bodies (such as tools, rags, equipment, etc.) on the machine;
- the machine does not make strange noises after switch-on; in this case, stop it immediately and trace
thecause;
- all safety housings are properly closed.

MAINTENANCE REGULATIONS

During cleaning and maintenance of the machine or the replacement of parts, always switch off the motor.
Do not use naked fl ames, do not cause sparks and do not smoke close to the fuel tank when the fi ller cap is open.
WARNING!
All maintenance, overhaul or repair work must only be carried out by specialised staff or an authorised
service centre.

ENGINE

Carefully follow the instructions in the OPERATION AND MAINTENANCE manual of the engine.
Every 8-10 hours check the oil level in the engine by using dipstick 5.
Change the engine oil using the sump drain hose 6 and fi lter 2 (See table: MAINTENANCE SCHEDULE)

ENGINE CHECK POINTS

1. fuel fi lter (DIESEL Versions)
2. engine oil fi lter (DIESEL, PETROL, PETROL-LPG Versions)
3. engine coolant liquid tank cap. (only BOXER D version )
4. engine air fi lter
5. engine oil level dipstick
6. engine oil drain hose
7. expansion tank (only versions SUPER BOXER D - BOXER SK)

ENGINE POWER SUPPLY

Replace the fuel fi lter 1 every 250 working hours. (DIESEL Versions)

ENGINE COOLING

Check the motor coolant through the cap 3 (BOXER D ) or the expansion tank 7 (SUPER BOXER D and BOXER SK )
every 10 hours.
46

MAINTENANCE

(FIG.5 - 1/2)