Table of Contents
Advertisement
3
ALL OTHER PIVOT POINTS
-
Clean all plvot
polnisand Ihnkagesand I u b r ~ c a t e ~ ~ ~ t h S A E N o
30
wt
0 1
every 25 operailng hours
4 TRANSAXLE - The transaxle is lilled for l ~ f e and
should not requlrf a d d ~ t ~ o n a l lubrlcatlon Make
p e r ~ o d i c v ~ s u a l lnspectlons for damage or leaks
every 100
operating
hours I f damage or eaKs
occur consult :ransaxle manufacturer
5
5ervlce
manual for proper lubr~catlon and malntence
s p e c l l ~ c a l i o n s (Lubricant type
E
P L ~ t h ~ u m
Grease 36 ounces)
MAINTENANCE:
1. GENERAL
-
Make a visual inspection for loose or
damaged parts. Check nuts and bolts periodically
to insure against looseness caused by vibration or
rough handling. Damaged parts should be re-
paired or replaced.
2. BATTERY
-
Terminals should be tight and free of
corrosion. Battery hold down bracket should be
snug over battery. Top of battery should beclean
and dry. Check level of electrolyte. Add clean
distilled water as needed.
3 BELT
-
Inspect traction drive belt for cracking.
excesslve wear and for proper tension. Refer to
"ADJUSTMENTS AND SERVICING
-
TRAC-
T I O N D R I V E B E L T " s e c t i o n t o check b e l t
tension.
4. TIRE PRESSURES -Recommended tire pressure
for both front and rear tires is 10 p.s.i.
5 .
P.T.O. WARNING L I G H T - Periodically check the
operation of this light. Check as follows:
a.
Turn ignition switch to "RUN" position.
(DO NOT start englne)
b. Move P.T.O. switch to "ON" position.
NOTE: Warning light should come on.
c.
Move P.T.O. switch to "OFF" position.
NOTE. Warning light should turn off.
d. Turn ignition switch to " O F F posltlon.
A
WARNING: Proper operation of this light is
mandatory. Personal bodily injury may occur
if light is n o t operating properly. Reference
"ELECTRICAL SYSTEM
-
P.T.O. WARNING
LIGHT" for servicing.
ADJUSTMENTS
AND SERVICING
ATTENTION: All procedures listed in this section for
adjustments and servicing of the tractor are des-
cribed with the attachment removed. Reference "AT-
TACHMENTS" section o f this ser'iice manual for all
iniormation specific to the attachment mounted on
this tractor.
ENGINE:
1 Refer t o Engine Manufacturer's Service Manual
for all adjustments and servicing information
2. Maximumengine RPM highspeed, noload, range
is 3500 to 3700 RPM.
3. Engine Removal
-
A
WARNING: T o avoid accidental starting, re-
move spark p l u g wires and secure away from
spark plugs. Turn ignition switch " O F F .
A
WARNING: T o avoid severe burns, D O NOT
attempt this procedure when engine is hot.
Wait for engine and muffler to c o o l down
before proceeding.
A.
Before this procedure is performed. the at-
tachment should be removed from this trac-
tor as outlined in "ATTACHMENT"section o f
this service manual.
B. Loosen ( d o not remove) each capscrew se-
curing
right and left transaxle pulley belt
guides to main frame. Swing belt g u ~ d e s out
of the way. (Fig.
4)
Left
I
11
I
amaxle Pulley
,
Loosen T h ~ s Capscrew
Belt
Guide
1
To Loosen Belt Guide.
Form
No. 620-292
FIG.
4
Yard Tractor 3
Hide quick links:
Advertisement
Table of Contents
