Hyundai HSL1500T Wheel Manual page 39

4. Engine Compartment
The engine compartment is completely enclosed for
component protection and lockable to discourage
vandalism. For servicing, the rear door swings open and
the engine cover hinges up (Fig. 4.2F).
To open, reach through the opening in the rear door (Fig.
4.2F), and pull outward releasing the door latch. Then,
open the radiator/oil cooler by removing the pins located
on the side of the radiator (Fig. 4.2G). Always remember
to lower the engine cover before closing the rear door.
IMPORTANT
4. 3 DAILY SERVICE CHECK
1. Hydraulic Oil Level
Check the oil level with the machine on a level surface
with the lift arms down and the attachment grounded.
Open the rear door and check the oil level sight glass (Fig.
4.3A). If oil is apparent the oil level is satisfactory.
If necessary to add oil, remove the reservoir cap located
at the top of the oil reservoir and add oil until oil appears
in the oil level sight glass.
Use a good quality 10W30 oil which meets the API
classification SJ only.
WARNING
2. Air Cleaner
The loader is equipped with an air cleaner restriction
warning lamp. Should this lamp illuminate, shut off the
engine and determine cause. Possibly a plugged air filter.
Figure 4.3B shows the air cleaner.
Check that all hose clamps are tight and the hose is
undamaged. Check the vacuator valve for damage (Fig
4.3B).
See Section 4.9 for Air Cleaner Maintenance.
40
4. MAINTENANCE
Keep the rear door
and radiator closed
and latched except
for servicing.
To avoid personal injury:
Stop, Cool and Clean the
engine of flammable
materials before
servicing. Never service
or adjust machine with
engine running.
Radiator
Pins
Radiator Pin
C644
Air Cleaner
Vacuator Valve
C3779
Door Latch
Fig. 4.2F
Fig. 4.2G
Fig. 4.3A
Fig. 4.3B
C4241
C4241