Troubleshooting; Side Burner Troubleshooting; Grill Out™ Handle Light Troubleshooting - Weber Summit 56221 Owner's Manual

PRobLEm
burners burn with a yellow or
orange flame, in conjunction with
the smell of gas (this is normal for
the burner lighting tube).
Symptoms:
burner does not light, or flame is
low in hi position.
experiencing flare-ups:
m Caution: do not line
the bottom tray with
aluminum foil.
burner flame pattern is erratic.
flame is low when burner is on hi.
flames do not run the whole length
of the burner tube.
inside of lid appears to be "peeling."
(resembles paint peeling.)
Cabinet doors are not aligned.
if problems cannot be corrected by using these methods, please contact the Customer service representative in your area using the contact information on our
web site. log onto www.weber.com
PRobLEm
side burner does not light.
flame is low in hi position
push button ignition does not work.
if problems cannot be corrected by using these methods, please contact the Customer service representative in your area using the contact information on our
web site. log onto www.weber.com
PRobLEm
weber Grill out™ handle light
does not light.
if problems cannot be corrected by using these methods, please contact the Customer service representative in your area using the contact information on our
web site. log onto www.weber.com

TRoUbLESHooTING

cHEcK
Inspect Spider/Insect Screens for possible obstructions . (Blockage
of holes .)
Is fuel hose bent or kinked?
Does Burner light with a match?
Did you use the snap igniter several times until the main burner lit
(refer to "MAIN BURNER IGNITION")?
Does the igniter work? Do you see a spark when you repeatedly
use the snap igniter?
Are you preheating barbecue in the prescribed manner?
Are the cooking grates and Flavorizer
burned-on grease?
Is the bottom tray "dirty" and not allowing grease to flow into catch
pan?
Are burners clean?
The lid is porcelain enamel or stainless steel, not paint . It cannot
"peel" . What you are seeing is baked on grease that has turned to
carbon and is flaking off .
this is not a defeCt.
Check the adjustment pin on the bottom of each door .
.
®

SIDE bURNER TRoUbLESHooTING

cHEcK
Is gas supply off?
Is the fuel hose bent or kinked?
Does burner light with a match?
.
®
GRILL oUT™ HANDLE LIGHT TRoUbLESHooTING
cHEcK
Are the batteries old?
Are the batteries installed correctly?
Is the lid in the up position with the power button ON?
Is the Weber Grill Out™ Handle Light activated?
Is the Weber Grill Out™ Handle Light positioned correctly on the
handle?
.
®
Clean Spider/Insect Screens (refer to "ANNUAL MAINTENANCE") .
Straighten fuel hose .
Clean burners (refer to "MAINTENANCE") .
Make sure to hold the control knob in for two seconds after
snapping the igniter and seeing the orange flame from the burner
lighting tube .
Try manually lighting the burner (refer to "MAIN BURNER
MANUAL IGNITION") . Call customer service .
All burners on HI for 10 to 15 minutes for preheating .
® bars heavily coated with Clean thoroughly (refer to "CLEANING") .
Clean bottom tray .
Clean burners (refer to "MAINTENANCE") .
Clean thoroughly (refer to "CLEANING") .
Loosen adjustment nut/s . Slide door/s until aligned . Tighten nut .
Turn supply on .
Straighten hose .
If match lights burner, check igniter (refer to "SIDE BURNER
MAINTENANCE") .
Replace batteries .
Refer to assembly illustration .
Light will activate when lid is open .
Press the power button .
Adjust position (refer to assembly illustration) .
SoLUTIoN
SoLUTIoN
SoLUTIoN
WWW.WEbER.com
® 21