Trouble Shooting - Royal Enfield BULLET TRIALS 500 Owner's Manual

TROUBLE SHOOTING

We have listed below a few basic checks in case your motorcycle is not functioning. If in case the problem is not rectified after these checks, it is necessary
to get the motorcycle checked by a Royal Enfield Authorised Dealer / Service Center to rectify the problem and to ensure trouble free performance.
S y m p t o m
O b s e r v a t i o n s
1. Ignition/Engine stop switch is in "OFF" position
2. Very low / No fuel in the fuel tank.
E n gin e D o e s
3. Lights / horn very dim.
no t s t a r t
4. Electricals not working.
5. Engine Cranking but not starting.
6. MIL glowing continuously
(Warning indicator lamp).
E ngine St a r t s
1. Engine shuts off as soon as throttle is closed.
BUT shuts off
i m m e d i a t e l y
2. Engine Starts but Shuts of immediately.
C h e ck f o r / R e me d y
Switch "ON" Ignition / Engine stop switch.
Check Fuel level / fuel meter and fill fuel.
Weak/Discharged battery. Replace Battery.
1. Battery completely dead. Replace battery.
2. Fuse Blown. Replace appropriate fuse.
Note: If fuse blows again, contact Authorised Service Center.
Spark plug Cap/wire disconnected. Reconnect.
Check if gear is engaged and the sidestand is down.
If the ambient Temperature is low use Bistarter.
Contact Authorised Service Center.
Idling RPM set too low / setting disturbed.
Contact Authorised Service Center for resetting the Idling
RPM.
Check if the MIL Lamp is glowing; If yes, Contact Authorised
Service Center.
59