Operating Instructions; Glass Information; Glass Frame Removal; Glass Cleaning - Majestic DVBR36 Homeowner's Installation And Operating Manual

Glass Information

Only glass approved by CFM Corporation
may be used for replacement.
•
The use of any non-approved replacement glass will
void all product warranties.
•
Care must be taken to avoid breakage of the glass.
•
Do not operate appliance with glass front
removed, cracked or broken.
•
Replacement glass (complete with gasket) is
available through your CFM Corporation dealer
and should only be installed by a licensed
qualified service person.

Glass Frame Removal

1. Turn off gas.
2. Let the fireplace cool if it has been operating.
3. Remove valve cover. (Fig.47)
4. Release the two (2) clamps at the bottom of the
window frame by pulling back on the clamp handles.
(Fig. 48)
5. Lift off the glass frame as shown. (Fig. 48)
6. To reinstall glass follow the above procedure in re-
verse.
Valve Cover
Valve
Fig. 47 Valve cover location.

Glass Cleaning

G584-500
It is necessary to clean the glass periodically. During
Remove valve cover
start-up condensation, which is normal, forms on the
2/99 djt
inside of the glass and causes lint, dust and other
airborne particles to cling to the glass surface. Also
initial paint curing may deposit a slight film on the glass.
It is therefore recommended the glass be cleaned
20000584

Operating Instructions

Pins
Locating Holes
G584-500
DVBR Series Direct Vent Gas Fireplace
Clamps
Glass
Panel
Fig. 48 Glass panel removal.
two or three times with a non-ammonia household
G584-501
Remove glass frame
cleaner and warm water (gas fireplace glass cleaner
2/99 djt
is recommended). After initial use glass should be
cleaned two or three times during heating season.
Clean glass after first two weeks of
operation.
Do not clean glass when hot.
Do not use abrasive cleaners.
Do not strike or slam the glass.

Replacement of Ceramic Hearth Panels

1. Remove glass.
2. Remove two (2) hex nuts securing grate to hearth
pan. (Fig. 49)
3. Set left and right panels on hearth and bring towards
front of unit.
4. Replace grate assembly.
Grate
Hearth Panels
Front of Unit
Fig. 49 Hearth panel location.
Glass Frame
Fireplace
Front
Glass
Panel
Pull Clamp
Hook
G584-501
Burner
H100
hearth Panels
3/15/99 djt
H100
23