Related Manuals for Volvo RTI S6
Summary of Contents for Volvo RTI S6
- Page 1 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Instruction No Instruction No Version Version Part. No. Part. No. 8685716 8685716 RTI S60 RTI S60 © Volvo Car Corporation RTI S60- 8685716 - V1.0 Page 1 / 34...
- Page 2 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Equipment A0000162 A0000161 A0801178 M8802509 © Volvo Car Corporation RTI S60- 8685716 - V1.0 Page 2 / 34...
- Page 3 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden M3903563 © Volvo Car Corporation RTI S60- 8685716 - V1.0 Page 3 / 34...
- Page 4 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden M3903789 © Volvo Car Corporation RTI S60- 8685716 - V1.0 Page 4 / 34...
- Page 5 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden M8503983 © Volvo Car Corporation RTI S60- 8685716 - V1.0 Page 5 / 34...
- Page 6 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden M3903786 © Volvo Car Corporation RTI S60- 8685716 - V1.0 Page 6 / 34...
- Page 7 Certain steps in the instructions are only presented in the form of images. Explanatory text is also given for more complicated steps. In the event of any problems with the instructions or the accessory, contact your local Volvo dealer. Note! This accessory requires software unique to the car. Preparations Move the left front seat and the gear selector lever to the rearmost positions.
- Page 8 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Carefully remove the loudspeaker grille (1) on the dashboard. Use a weatherstrip tool or similar. M3902612 Remove the screws (1). Remove the bracket (2). M3902613 © Volvo Car Corporation RTI S60- 8685716 - V1.0...
- Page 9 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Applies to cars with a centrally mounted loudspeaker Remove the three screws in the loudspeaker (1) Lift up the loudspeaker. Disconnect the connector (2) Place the loudspeaker to one side. M3902614 Pry off the panel in front of the gear selector lever. Use a weatherstrip tool as illustrated.
- Page 10 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Press in the catches on the front edge of the gear selector lever panel. Lift the panel upwards, first the front edge and then the rear edge. Remove the panel around the gear selector lever.
- Page 11 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Angle the dashboard environment panel outwards so that it is possible to insert a couple of fingers between the centre console and the reverse of the panel Remove the dashboard environment panel by pulling it downward, maintaining the same angle.
- Page 12 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove: the left-hand side panel (1) from the centre console. First turn the clip. Pull the panel outwards and backwards the sill trim panel (2) at the left front door the covers (3) and the screws (4). New screws can be found in the kit.
- Page 13 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the rear seat cushion (1). First pull the front edge of the seat cushion up. Pull the cushion forwards. Then lift the seat cushion out. D8503390 Remove the sill trim panel at the left rear door.
- Page 14 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Fold both the rear backrests forward Remove the seat belts from the guides (1). M8503545 Remove the clip (1) at the side of the left-hand side cushion Pull out the top edge of the left front panel in the cargo compartment to access the upper catch for the side cushion Repeat the operation on the right-hand side.
- Page 15 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the left-hand side cushion. First press in the catches (1) at the top of the reverse of the side cushion. Pull the cushion out slightly Grasp the cushion using both hands. Twist anti-clockwise until the catches on the inside release Remove the side cushion.
- Page 16 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the rubber strip at the rear edge on the left-hand rear door frame Grasp the top edge of the C-post panel. Pull (A) the panel inwards until the three clips (1) release Then pull (B) the panel straight up.
- Page 17 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the cargo compartment carpet at the rear edge. First turn the two knobs (1) 90°. M8503480 Pull up the front of the cargo compartment carpet. Fold the front half back over the rear half of the cargo compartment carpet.
- Page 18 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Slide the entire cargo compartment carpet forward slightly. Twist slightly to remove the carpet through the tailgate opening Remove the cargo compartment carpet. M8503482 Press the centre of the clips at the lower edge of the folding...
-
Page 19: Cable Routing
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Turn the handle (1) on the right and left-hand sides. Turn the handle through 90°. Fold the side panels down. Lift the panels out. Place the left- hand side panel to one side. A new panel is in the kit Pull the tailgate sill trim panel (2) forwards on the right and left- hand sides until the clips on each side release. - Page 20 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Cable routing Route the wiring (A in the kit illustration) for the display screen and the radio, and the loose cable for the display screen with the ten pin connectors (B in the kit illustration) to the radio socket between the air duct (1) and the stay (2).
- Page 21 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Route the wiring (1): out along the right-hand side of the cable duct (2) and under the wiring which is connected there. Remove the connectors if necessary up along the top of the wheel arch and out through the hole at the top of the wheel arch down along the wheel arch.
- Page 22 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Connect the new routed red and white cable to the outer terminal (1) on the reverse of fuse socket number 10 on the fuse holder. Remove the decal (2). Carefully pry up the red secondary locking on the face in the end nearest terminal 10.
- Page 23 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Insert a small screwdriver in the socket on connector A as illustrated Twist the screwdriver so that the holders open. At the same time press the connector out to the side Connect the white (W) cable to terminal 15 and the green (GN) cable to terminal 17.
- Page 24 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Installing the DVD reader Does not apply to USA Remove the existing aerial amplifier (if applicable) Connect the cable (2) for the new aerial amplifier (1) to the connector (3) for the aerial in the rear bumper by the right-hand...
- Page 25 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Take four screws, the bracket and the DVD reader from the kit. Tighten the DVD reader at the bracket. M3903787 Take the spring nut (1) from the kit. Press the spring nut on the panel edge on the underneath of the socket (2) in the panel.
- Page 26 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Connecting the DVD reader Connect: the cable (1) for the display screen the power supply cable (2) the cable (3) for the Global Positioning System (GPS) aerial the cable (4) to the aerial amplifier the DIN cable (5) for the radio.
- Page 27 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Installing and connecting the display screen Applies to cars without a centrally mounted loudspeaker Install the bracket (1) on the display (2). Only use screws at position (3) and screw and washer at position (4). Screws and washer can be found in the kit.
-
Page 28: Finishing Work
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Applies to cars with a centrally mounted loudspeaker Install the centrally mounted loudspeaker in the cut out in the bracket for the display screen Tighten the loudspeaker into place. Use the four screws... - Page 29 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Finishing work Connect the green female connector on the new cable harness, to the green male connector disconnected from the radio Connect the other two large connectors to the radio Connect the other connectors removed from the radio Reinstall the radio Connect the connectors to the dashboard environment panel.
- Page 30 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Turn the steering wheel 90º to the position illustrated, so that the two holes on the reverse of the steering wheel are accessible. M6400668 Insert a screwdriver in the hole on the reverse of the steering...
- Page 31 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Fold the steering wheel module out Remove the two connectors (1) for the sender wiring on the airbag. Note! The connectors are tightly secured. Do not use tools to disconnect the connectors Place the steering wheel module to one side.
- Page 32 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Illustration A Place the steering wheel in a suitable position and cut using a small knife following the existing markings. Note! Ensure that the knife is held so that cutting is carried out at right angles to the reverse of the steering wheel.
- Page 33 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Tighten the keypad and cover around the spoke. Use the screws. M3903757 Position the horn as illustrated Connect the installed keypad connector to the reverse of the keypad on the right-hand side of the horn. The cable from the installed keypad is extremely short and the connector is difficult to connect.
- Page 34 Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Check that the two springs (1) are in position Press the two connectors for the sender cables for the airbag into the steering wheel module. Note! The wiring must be routed through the existing holder (2).
Need help?
Do you have a question about the RTI S6 and is the answer not in the manual?
Questions and answers