Page 4
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden A3903163 Any comments on this publication? Please contact your nearest dealer. Thank you! Publication no: MA 8682160, Issue: 2002-08 Comments:......................
Page 5
Work on the SRS/SIPS systems or related components must always be order of operation is repeated in the text section carried out by an authorised Volvo workshop. Cut out the text page in order to follow the illustrations and text at Is the car equipped with SRS (supplemental restraint system)? the same time.
Page 6
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden in the centre console, in front of the parking brake. WARNING! The air bag inflation areas must not be obstructed. Never place any objects, such as upholstery or accessories, within these areas.
Page 7
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden Preparations Remove the left and right-hand side panels from the centre console. Pull the panels free at the front edge and then backwards until all the clips have released.
Page 8
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden Preparations Illustration A Remove the loudspeaker grille as follows: Take a length of 1.5 mm (1/16”) diameter welding rod. Bend one end to 90°...
Page 9
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden R3904129 Preparations Lower the steering wheel to the lowermost position. Pull the steering wheel to the rearmost position Remove the two screws at the top edge of the combined instrument panel surround Carefully pry off the rubber seal from the upper steering column cover.
Page 10
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden Preparations Remove the screws holding the bracket for the dashboard environment panel and the control module Pull out the bracket at the lower edge. Pull downwards from the top edge of the...
Page 11
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden Installing the carphone holder Take the reinforcement panel (1) and the two screws from the kit Position the carphone holder wiring so that it is routed on the reverse of the...
Page 12
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden Installing the carphone holder Illustration A applies to Nokia Tighten the carphone holder (1) onto the mounting plate (2) using the screw (3) Install the cover (4).
Page 13
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden Installing the carphone holder Applies to all models Take the two large cable harnesses from the kit. Connect them to each other.
Page 14
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden Installing the handsfree box Applies to all models: Take two screws and nuts from the kit. Install the bracket with the handsfree box on the existing bracket at the lower edge of the centre console.
Page 15
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden Head restraint preparations Does not apply to cars with leather upholstery Remove the upholstery from the head restraint. If the zip fastener catch is missing: Disconnect the clamps at the ends of the zip fastener.
Page 16
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden Installing the head restraint Insert a curtain wire from the bottom and upwards on the reverse of the backrest between the upholstery and the padding Tape the switch from the microphone cable to the curtain wire.
Page 17
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden Cable routing to the accessory electronic module (AEM) Remove the cover (1) on the left front mounting on the right-hand front seat by prying off the front edge Pry off the front edge of the right panel (2).
Page 18
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden Cable routing to the accessory electronic module (AEM) Remove the panel in the right-hand front seat mounting on the right-hand seat in the second row.
Page 19
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden Cable routing to the accessory electronic module (AEM) Applies to cars with three rows of seats and integrated carrier bag...
Page 20
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden Cable routing to the accessory electronic module (AEM) Pull up the left and right sides of the carpet at the right-hand front seat slightly.
Page 21
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden R3703023 Cable routing to the accessory electronic module (AEM) Applies to cars with two rows of seats Route the cable on the left-hand side of the seat belt mounting at the front edge...
Page 22
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden Connecting to the accessory electronic module (AEM) Remove the black catch holding the black switch in place in the connector by pulling in the direction of the arrow Remove the black switch.
Page 23
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden Installing the integral aerial Remove the panel on the right end of the dashboard. M8502816 Installing the integral aerial Pry off the cover on the grab handle in the right-hand front door. Remove the screws.
Page 24
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden Installing the integral aerial Fold down the cover (1) by carefully pulling down the front edge of the cover Squeeze the catches (2). Pull the front edge of the panel downwards. Then pull the rear edge off.
Page 25
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden Installing the integral aerial Push the carpet to one side by the right-hand front seat Take the extension cable (1) from the kit. Route the cable between the A-post...
Page 26
Installation instructions, accessories - Handsfree Installation instructions, accessories - Handsfree Volvo Car Corporation Göteborg, Sweden Volvo Car Corporation Göteborg, Sweden the loudspeaker grille. Installing the integral aerial Turn the ignition key to position II Reconnect the battery negative lead Reinstall the storage boxes and floor hatch(es)
Need help?
Do you have a question about the 2003 XC90 and is the answer not in the manual?
Questions and answers