Page 4
Explanatory text is also given for more complicated steps. In the event of any problems with the instructions or the accessory, contact your local Volvo dealer. Note! Wiring A is for vehicles with an internal amplifier that is located in the media player.
Page 5
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Preparations Set the ignition key to position 0. IMG-331668 Open the glovebox. Pry off the panel in front of the center console. It is secured with two clips on each short side.
Page 7
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Detach the clip holding the vent from the glove compartment. IMG-244221 Remove the rubber mat from the glovebox. Remove the five screws in the opening. Pull the glovebox straight back so that the two hidden clips at the upper edge release.
Page 9
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the clips at the rear edge of the soundproofing panel and remove it. J8504871 Detach the surround around the display and media player. Press in the catch in one of the upper corners of the surround using a small screwdriver.
Page 10
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the display with the infotainment control module (ICM). It is secured by two hidden clips. Hint Grip the control module with both hands and pull the control module straight out of the center console.
Page 12
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the rear seat cushion by first pressing the outer edges of the cushion backwards and then by pulling them upwards so that the outer hooks release. IMG-263944 Lift the cushion straight up in the middle so that the inner hooks release.
Page 13
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the rear cup holder from the rear tunnel compartment. Pry at the leading edge and press in the catches, first at the leading edge and then on the sides. IMG-263946 Remove the screws.
Page 14
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the rear tunnel compartment by pulling it upward/rearward so that it releases from its catches. IMG-263948 Remove the front storage compartment by prying it off at the front edge using a weatherstrip tool and lifting it out.
Page 15
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the two screws along the front edge of the tunnel console. IMG-270744 Illustration A Carefully lift up the catches in the tunnel compartment's leading edge. Use special tool 9995919. Illustration B...
Page 16
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the screws. IMG-263209 Applies to cars with manual gearbox Remove the gear selector lever boot from the center console. First pry it off at the front edge using a weatherstrip tool and then unhook it at the rear edge.
Page 17
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the two screws. Remove the connector on the reverse of the center console. Remove the center console. IMG-240085 Remove the two clips securing the cables to the media player by first pressing them to the sides and then pulling them away downwards.
Page 18
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the two screws from the bottom of the media player. Pull out the media player. Disconnect the connector on the reverse side. Note! Note how the wiring is packed on the reverse. The fibre optic cables are easily damaged and must not be bent to a radius less than 25 mm (1“).
Page 19
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Installing the control panel Clean the area on the center console as illustrated, which corresponds to the size of the double-sided adhesive tape. Use a solution of 25% isopropanol and 75% water, as well as a lint free cloth.
Page 20
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the protective film from the tape and press the control panel edge to edge with the climate panel and according to the dimensions in the image. IMG-331707 Press the cable securely into the compartment that is in the joint between the front and rear side of the center console.
Page 23
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Clean the microphone and the headlining in the area illustrated, which corresponds to the size of the double-sided adhesive tape. Use a solution of 25% isoproanol and 75% water, as well as a lint free cloth.
Page 24
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Route the microphone cable on the top side of the ceiling panel. The microphone cable must point inwards so that it is not visible. IMG-248569 Pull the cable down along the A-pillar to the dashboard.
Page 26
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Secure the microphone cable using a small tie-strap. IMG-222680 Installing the control module Installing the control module Take the cable harness and control module from the kit. Connect the cable harness to the control module (1).
Page 27
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Get a thick foam tape from the kit and fasten it on the front of the control module. Fold up the foam tape around the corners and edges of the control module.
Page 28
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the sill trim panel at the right-hand front door. First pull off the front edge of the sill trim panel so that the clip releases. Then continue backward until the remaining clips on the underside have released.
Page 29
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Place the control module with the thick foam tape forward, against the bulkhead. IMG-256726 Fold aside the cable harnesses (1) so that they do not end up between the control module and floor mat.
Page 30
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Connecting Fold the carpet to the right of the center console. IMG-239780 Applies to cars with internal amplifier Take the relay and two thick pieces of foam tape from the kit. Connect the connectors from cable harness A to the relay.
Page 31
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Applies to cars with internal amplifier Place the relay between the carpet and the climate control unit as illustrated. IMG-239783 Connect the connectors as illustrated. Applies to cars with internal amplifier 1. Connect cable harness A to the cable from the control module.
Page 32
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Place the connectors and the excess wiring inside the center console. Fold back the carpet. IMG-239781 Take two large tie straps from the kit and secure the cable from the microphone on top of the collision pipe.
Page 33
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Reinstall: gear lever gaiter, starting at the trailing edge. and slide the tunnel console forward so that the lugs secure it. At the same time align the floor carpet on the right and left-hand sides.
Page 38
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the screw clip and load securing eyelet with its screw. Applies to cars with a tool box Take the tools out of the toolbox. Remove: the screw clip. the screw. the toolbox.
Page 39
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the cover for the tailgate's stop, by prying, with a weatherstrip tool, between the cover and the sealing strip. Carry this out on both the left and right-hand sides. Note! On right-hand drive vehicle's, the procedure only needs to be carried out on the left-hand side.
Page 40
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden For cars with emergency release handle in cargo compartment Remove the emergency opening handle by pressing out the pin at the eye and unhook the wire. IMG-242967 Remove the two screws in the sill molding.
Page 42
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Steps 75-82 apply to both right and left-hand drive cars. On right-hand drive cars, the procedure only needs to be carried out on the left-hand side in the cargo compartment. Remove the rubber stop on the roof's stop bracket on both the right and left-hand sides.
Page 43
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the lock for the load divider by prying between the carpet and lock using a weatherstrip tool. Carry this out on both the right and left-hand sides. Remove the connector on the left- hand lock.
Page 44
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the cover for the stop bracket on both the left and right- hand sides. IMG-242969 Mark out the stop brackets for the roof in relation to the screw and the nut.
Page 45
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Detach the four clips on the side panels on both the right and left -hand sides. IMG-221976 Remove the side panels on both the left and right-hand sides, by unhooking them from the stop lugs at the front edge and then pulling them outwards and upwards so that they release from the weatherstrip.
Page 46
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the screw and the rear sill trim panel. IMG-230432 Route the cable B between the floor carpet and the sill. Position the cable so that it is not trapped or damaged.
Page 48
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Applies to left-hand drive cars Route the cable harness along the existing cable harnesses in the cargo compartment, away to the amplifier. Secure with three small cable ties. IMG-231442 Applies to cars with subwoofer amplifier Remove the subwoofer amplifier by removing the screws and unplugging the connectors.
Page 50
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Remove the green connector. IMG-230468 Remove cable harness C from the kit. Route the white connector for the cable harness through the hole from the compartment behind the amplifier and out to the cargo compartment.
Page 51
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Connect cable harness C to the amplifier as follows: Connector (1) that was disconnected from the amplifier is connected to the female connector (2) on the adapter cable. Connector (3) is connected to the amplifier.
Page 52
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Take the relay from the kit. Connect the connect from cable harness C and the newly routed cable harness connector to the relay. Tape two thick pieces of foam tape around the relay.
Page 53
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden Finishing work Applies to all models Reinstall the connectors to the rear section of the glove box. Note the color marking on the cable for the right-hand connector. IMG-231504 Passenger compartment Reinstall: the lower vent.
Page 54
Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden the cover for the cargo compartment stop. load securing eyelets, tightening torque 24 Nm (18 lbf.ft.). the toolbox. the spare wheel, if in place. divider, remove the cable ties, tightening torque 10 Nm (7.3 lbf.ft).