Download
Share
Print this page
  1. Manuals
  2. Brands
  3. Pentair Manuals
  4. Water Pump
  5. Hydromatic JB-1
  6. Installation and service manual

Pentair Hydromatic JB-1 Installation And Service Manual

Sewage ejector pump package
Hide thumbs
1
2
3
4
5
6
7
8

Advertisement

Quick Links

Download this manual
293 WriGhT STreeT, Delavan, Wi 53115 WWW.hyDrOmaTic.cOm
Ph: 888-957-8677
269 Trillium Drive, KiTchener, OnTariO, canaDa n2G 4W5
Ph: 519-896-2163
© 2013 Pentair, ltd. all rights reserved.
NOTE! TO ThE iNSTallEr: Please make sure
you provide this manual to the owner of the
pumping equipment or to the responsible party
who maintains the system.
InstallatIon and servIce Manual
Sewage Ejector Pump Package
JB-1 System
W-03-373 (rev. 03/04/13)

Advertisement

loading

Related Manuals for Pentair Hydromatic JB-1

Summary of Contents for Pentair Hydromatic JB-1

  • Page 1 293 WriGhT STreeT, Delavan, Wi 53115 WWW.hyDrOmaTic.cOm Ph: 888-957-8677 269 Trillium Drive, KiTchener, OnTariO, canaDa n2G 4W5 Ph: 519-896-2163 W-03-373 (rev. 03/04/13) © 2013 Pentair, ltd. all rights reserved.

  • Page 2: General Information

    grounded plug to help protect equipped with a separate 15 General you against the pos si bil i ty of amp circuit breaker according electrical shock. Do not remove to the National Electrical Code. Information the ground pin from the plug. 5.
  • Page 3 Failure to heed above cau tions nOTE: The above recommendations bowl/flush tank will be parallel could result in injury or death. meet or exceed national and most to the pump housing and piping.) local building codes, and are meant 5. Set pump in pump housing only as rec om men da tions when Pump System with discharge toward the right...
  • Page 4 WArning: The tank and lid 11. The discharge pipe should 17. Lubricate 2" rubber pipe seal will ex pand with the water protrude approximately 4" with soapy water and push it column pressure while tested. above the sur face of the lid. into 3"...
  • Page 5 Pump END VIEW Warning Figure 1 SIDE VIEW Figure 2...

  • Page 6: Pump Troubleshooting

    2. Discharge gate valve, if used, Fuse blows or circuit break er Pump may be closed. trips when pump starts. Troubleshooting 3. Pump may be air locked. Start 1. Inlet in pump base may be and stop several times by clogged.
  • Page 7 JB-1 System Parts List Figure 3— Installation Hardware Kit item Description Qty. 1/4"–20 x 5/8" Hex Head Bolts 20 Flat Washers–.320 I.D. 5/16" x 2" Stud and Nuts Check Valve Wax Ring (Retail Boxed) 1/2" Foam Gasket Material 2" Adapt-A-Flex Pipe Grommet Adapt-A-Flex Pipe Grommet for Cords 2"...

  • Page 8: Limited Warranty

    Limited Warranty HYDROMATIC warrants to the original consumer purchaser (“Purchaser” or “You”) of HYDROMATIC Sump Pumps, Effluent Pumps, Sewage Pumps (other than 2-1/2”), and Package Systems, that they will be free from defects in material and workmanship for the Warranty Period of 36 months from date of manufacture. Our warranty will not apply to any product that, in our sole judgement, has been subject to negligence, misapplication, improper installation, or improper maintenance.