Download
Share
Print this page
Pentair STA-RITE J Series Owner's Manual
  1. Manuals
  2. Brands
  3. Pentair Manuals
  4. Water Pump
  5. Sta-Rite J Series
  6. Owner's manual

Pentair STA-RITE J Series Owner's Manual

60 cycle centrifugal pumps with tefc motors
Hide thumbs Also See for STA-RITE J Series:

Advertisement

Quick Links

Download this manual
H.P.
1/3
1/2
3/4
1
1-1/2
2
2-1/2
293 WRIGHT STREET, DELAVAN, WI 53115 WWW.STA-RITE.COM
PH: 888-782-7483
© 2012 Pentair, Ltd. All Rights Reserved.
CEntrIfUGAL PUMPS WItH tEfC MOtOrS
H.P.
1/3
JMBT-56
1/2
JMCT-56
3/4
JMDT-57
1
JMET-58
1-1/2
JMFT-40
2
JMGT-41
2-1/2
–
JHBT-61H
–
JHCT-61H
JHC3T-61H
JHDT-62H
JHD3T-62H
JHET-63H
JHE3T-63H
JHFT-51H
JHF3T-51H
JHGT-52H
JHG3T-52H
–
JHHG3T-53H
60 CYCLE "J" and "JB" SErIES
MODELS
MEDIUM HEAD MODELS
–
JBMBT-56S
JMC3T-56
JBMCT-56S
JMD3T-57
–
JME3T-58
JBMET-58S
JMF3T-40
JBMFT-40S
JMG3T-41
JBMGT-41S
–
JBMMGT-59S
HIGH HEAD MODELS
JBHBT-61S
–
JBHCT-61S
JBHC3T-61S
JBHDT-62S
JBHD3T-62S
JBHET-63S
JBHE3T-63S
JBHFT-51S
JBHF3T-51S
JBHGT-52S
JBHG3T-52S
JBHHGT-53S
JBHHG3T-53S
OWNER'S MANUAL
671T 0294
–
JBMC3T-56S
JBMD3T-57S
JBME3T-58S
JBMF3T-40S
JBMG3T-41S
JBMMG3T-59S
–
–
JBH2DT-62S
–
–
–
–
S257 (11/15/12)

Advertisement

loading
Need help?

Need help?

Do you have a question about the STA-RITE J Series and is the answer not in the manual?

Questions and answers

Related Manuals for Pentair STA-RITE J Series

Summary of Contents for Pentair STA-RITE J Series

  • Page 1 JHET-63H JHE3T-63H JBHET-63S JBHE3T-63S – 1-1/2 JHFT-51H JHF3T-51H JBHFT-51S JBHF3T-51S – JHGT-52H JHG3T-52H JBHGT-52S JBHG3T-52S – 2-1/2 – JHHG3T-53H JBHHGT-53S JBHHG3T-53S – 293 WRIGHT STREET, DELAVAN, WI 53115 WWW.STA-RITE.COM PH: 888-782-7483 S257 (11/15/12) © 2012 Pentair, Ltd. All Rights Reserved.
  • Page 2 Short length of straight pipe after reducer Tee and Priming Plug Important: Stop Priming All connections must Valve Plug be air tight Discharge Street Elbow to service Support suction pipe Union Eccentric Reducer, as required, so that Straight side up pump does not take Solid, level weight of pipe...
  • Page 3 DISCHARGE PIPING California Proposition 65 Warning This product and related accessories contain Increase pipe size from pump discharge port as shown in chemicals known to the State of California to cause Table I. Figure 1 (Page 2) depicts a recommended run of cancer, birth defects or other reproductive harm.
  • Page 4 ELECTRICAL WIRING WARNING Ground motor before 1. Install, ground, wire and maintain this pump in connecting to electrical accordance with electrical code requirements. Consult power supply. your local building inspector for information about Failure to ground motor codes. can cause severe or fatal 2.
  • Page 5 ELECTRICAL 8. Motor has automatic internal thermal overload Connect wires to motor according to wiring diagram protection. If motor has stopped for unknown reasons, below or in motor junction box. Be sure motor is thermal overload may restart it unexpectedly, which connected for correct line voltage.

  • Page 6: Pump Service

    SERVICE PUMP SERVICE 2. Turn seal plate over so seal cavity is up; clean cavity thoroughly. This centrifugal pump requires little or no service 3. Lubricate outside rubber surface or O-ring of other than reasonable care and periodic cleaning. ceramic seat with soapy water and press firmly Occasionally, however, a shaft seal may become into seal cavity with finger pressure.
  • Page 7 TROUBLE - CAUSES AND REMEDY TROUBLE AND CAUSE REMEDY FAILURE TO PUMP 1. Pump not properly primed. 1. Make sure pump casing and suction line are full of water. See priming instructions. REDUCED CAPACITY AND/OR HEAD 1. Air pockets or leaks in suction line. 1.
  • Page 8 2413T 0496 REPAIR PARTS LIST “J” SERIES WITH TEFC MOTORS - HIGH HEAD JHGT-52H Part JHG3T-52H JHHG3T-53H Description Used 2 HP 2-1/2 HP Motor, 2 HP, 230V, 1 Phase AE100GL-T AE100G5L-T Motor, 2 HP, 230/460V, 3 Phase AP100GL-T AP100G5L-T †2 Water Slinger 17351-0009 17351-0009...
  • Page 9 REPAIR PARTS LIST “J” SERIES WITH TEFC MOTORS - HIGH HEAD JHBT-61H JHCT-61H JHDT-62H JHET-63H JHFT-51H Part – JHC3T-61H JHD3T-62H JHE3T-63H JHF3T-51H Description Used 1/3 HP 1/2 HP 3/4 HP 1 HP 1-1/2 HP Motor, 115V, 1 Phase A100BH-T – –...
  • Page 10 This drawing is for use with Models having a capscrew configuration. 2409T 0496 SPC This drawing is for use with Models having a stud configuration. 2410T 0496 SPC...
  • Page 11 REPAIR PARTS LIST “J” SERIES WITH TEFC MOTORS - MEDIUM HEAD JMBT-56 JMCT-56 JMDT-57 JMET-58 Part – JMC3T-56 JMD3T-57 JME3T-58 Description Used 1/3 HP 1/2 HP 3/4 HP 1 HP Motor, 115V, 1 Phase A100BH-T – – – Motor, 115/230V, 1 Phase –...
  • Page 12 This drawing is for use with Models having a capscrew configuration. 2409T 0496 SPC This drawing is for use with Models having a stud configuration. 2410T 0496 SPC...
  • Page 13 REPAIR PARTS LIST “JB” SERIES WITH TEFC MOTORS - MEDIUM HEAD JBMBT-56S JBMCT-56S JBMDT-57S JBMET-58S Part – JBMC3T-56S JBMD3T-57S JBME3T-58S Description Used 1/3 HP 1/2 HP 3/4 HP 1 HP Motor, 115V, 1 Phase A100BH-T – – – Motor, 115/230V, 1 Phase –...
  • Page 14 2413T 0496...
  • Page 15 REPAIR PARTS LIST “JBH” SERIES WITH TEFC MOTORS JBHBT-61S JBHCT-61S JBHDT-62S JBHET-63S JBHFT-51S – JBHC3T-61S JBHD3T-62S JBHE3T-63S JBHF3T-51S Part – – JBH2DT-62S – – Description Used 1/3 HP 1/2 HP 3/4 HP 1 HP 1-1/2 HP Motor, 115V, 1 Phase A100BH-T –...

  • Page 16: Limited Warranty

    Limited Warranty STA-RITE warrants to the original consumer purchaser (“Purchaser” or “You”) of the products listed below, that they will be free from defects in material and workmanship for the Warranty Period shown below. Product Warranty Period whichever occurs first: Water Systems Products —...

This manual is also suitable for:

Jmbt-56Jbmbt-56sJmc3t-56Jmct-56Jbmc3t-56sJbmct-56s ... Show all