Table of Contents
Advertisement
INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
NOTICE:
DO NOT discard this manual!
Model(s):
EPA CERTIFIED WOODBURNING
FIREPLACE
Installation and service of this appliance should be performed by
qualified personnel. Hearth & Home Technologies recomends HHT
Factory Trained or NFI certified professionals.
Owner's Manual
Care and Operation
R
Quadra-Fire • Pioneer III Owner's Manual • 4182-900 • Rev D • 08/19
Pour demander un exemplaire en
français de ce Manuel
du propriétaire, visitez www.quadra-
fire.com/translations.
WARNING: If the information in these
instructions is not followed exactly, a fire
or explosion may result causing property
damage, personal injury, or death.
• DO NOT store or use gasoline or other flam-
mable vapors and liquids in the vicinity of this
or any other appliance.
• DO NOT overfire. Overfiring will void your
warranty.
• Comply with all minimum clearances to com-
bustibles as specified. Failure to comply may
cause house fire.
WARNING
HOT SURFACES!
Glass and other surfaces are hot during
operation AND cool down.
Hot glass will cause burns.
• DO NOT touch glass until it is cooled
• NEVER allow children to touch glass
• Keep children away
• CAREFULLY SUPERVISE children in same room as
fireplace.
• Alert children and adults to hazards of high temperatures.
High temperatures may ignite clothing or other flammable
materials.
• Keep clothing, furniture, draperies and other flammable
materials away.
WARNING
Fire Risk.
For use with solid wood fuel only.
Other fuels may overfire and generate poisonous
gases (i.e. carbon monoxide).
1
Advertisement
Table of Contents
Troubleshooting
Related Manuals for Quadra-Fire Pioneer-III-ABK
Summary of Contents for Quadra-Fire Pioneer-III-ABK
- Page 1 Factory Trained or NFI certified professionals. WARNING Fire Risk. For use with solid wood fuel only. Other fuels may overfire and generate poisonous gases (i.e. carbon monoxide). Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19...
-
Page 2: Table Of Contents
7. Creosote Formation 8. Opacity D. First Fire E. Lighting Instructions F. Heat Output Control G. Manual Override of Air Control H. Frequently Asked Questions I. Quick Start Guide Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 3: Welcome
U.S. ENVIRONMENTAL PROTECTION AGENCY - Certified to comply with 2020 particulate emission standards using cord wood. 4182-990A This wood heater was found to have an average emissions rate of 2.0g/hr using method ASTM E3053-17. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 4: Limited Lifetime Warranty
Firebox and heat exchanger Lifetime All replacement parts 90 Days beyond warranty period See conditions, exclusions, and limitations on next page. 4021-645H 10/15 Page 1 of 2 Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... - Page 5 THE EXTENT PROVIDED BY LAW, HHT MAKES NO EXPRESS WARRANTIES OTHER THAN THE WARRANTY SPECIFIED HEREIN. THE DURATION OF ANY IMPLIED WARRANTY IS LIMITED TO DURATION OF THE EXPRESSED WARRANTY SPECIFIED ABOVE. 4021-645H 10/15 Page 2 of 2 Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19...
-
Page 6: Btu & Efficiency Specifications
It is against federal regulations to operate this wood heater in a manner inconsistent with operating Quadra-Fire is a registered trademark of Hearth & Home instructions in this manual. Technologies. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 7: Important Safety And Operating Information
Clear Space Sides of Fireplace cause birth defects or other reproductive (from the FP opening) harm. For more information go to: www. P65Warnings.ca.gov. Figure 3.1 Clear Space Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 8: Firebrick
Failure to re- fireplace. place damaged components and make proper repairs can cause a structure fire. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 9: General Operating Parts
SBT Button Bottom access cover, outside air control, and fan speed control are located in behind the access panel. Figure 3.3 General Operating Parts Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 10: Smart Burn Technology System Activation
This is indicating that the appliance is trying to heat the room but there is only charcoal left and needs reloaded. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 11: Thermostat Location & Wiring To Fireplace
Continue inserting the wire into the fireplace and through the hole in the inner cover plate. See Figure 3.7. Figure 3.9 Thermostat wire installed through outer cover plate Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 12: Programmable Wall Thermostat Install
Figure 3.13 BATTERY BATTERY Figure 3.12 7. Snap the thermostat to the base plate. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... - Page 13 HOLD will appear on the display. To cancel, press on and off whenever the room temperature varies the HOLD button once again. from the desired set-point temperature. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19...
- Page 14 Wednesday, as the word COPY will appear on the screen for one second). 4. Continue in this pressing COPY button to set desired days with original setting. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19...
- Page 15 Figure 3.16 - Low battery icon buttons at that point the screen will return to normal. The clock will have to be changed to match the current day and time. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19...
-
Page 16: Outside Air
Glass may break or burning material may roll out. WARNING! RISK OF Fire! Do NOT install and or use any component not approved by Hearth & Home Tech- nologies. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 17: Fuel
Burning these materials may result in release of toxic fumes or render the heater ineffective and cause smoke. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 18: Hardwood Vs. Softwood
Air dry to a moisture content of around 20% • Alder - Soft wood - about nine months - Hard wood - about eighteen months NOTICE: Seasoning time may vary depending on drying conditions. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 19: Storing Wood
You may lively hot coals remain in order to rekindle the next load notice an industrial odor the first few fires. This is considered of wood. normal. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 20: Lighting Instructions
• Leave the door slightly open 1-2 inches (see Figure 3.26) Figure 3.23 Loading Wood Figure 3.22 Placing Kindling Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... - Page 21 (example 75°) after 13 hours. Time will vary depending on house size. Load fireplace by referring to the High Burn section. Figure 3.28 Door Fully Closed Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19...
-
Page 22: Heat Output Control
The results can be fatal. instructions in this manual. Keep all flammable liquids well away from the fireplace while it is in use. Combustible materials may ignite. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 23: Frequently Asked Questions
• Do NOT burn treated wood or wood with salt (driftwood). use. • May generate carbon monoxide if burn material other than • Combustible materials may ignite. wood. May result in illness or possible death. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 24: Quick Start Guide
Close and securely latch the door after the fire has started, and after refueling, to prevent: -Spillage of smoke, flame and carbon monoxide -Spillage of sparks, coals and logs -Over-firing DO NOT leave the appliance unattended with the door open. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 25: Maintenance And Service
• condition of door, surrounds and fronts • condition of glass and glass assembly • obstructions of combustion and ventilation air • obstructions of termination cap Clean: • glass • air passageways, grilles Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 26: Creosote (Chimney) Cleaning
Termination Caps Remove 2 screws from the front and back and lift the top off. TCT375 Terra Cotta Termination Cap Figure 4.1 Chimney & Termina- tion Cap Cleaning Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 27: Care And Cleaning Of Plated Surfaces
It may be necessary to adjust or tighten the door latch. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 28: Replacement Maintenance
• Use a hard water deposit glass cleaner on white film. rect placement. • Refer to maintenance instructions. WARNING Injury Risk. • Use only glass specified in manual. • DO NOT REPLACE with any other material. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 29: Firebrick Replacement
Install side bricks. Slide top of brick under clips on side of firebox and push the bottom of the brick until it is flush with the side of the unit. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 30: Thermocouple Replacement
(with the Thermocouple guard attached to it) down and off of the thermocouple. See Figure 4.6. Guard Remove (2) Allen Bolts Cover Plate Figure 4.6 Cover Plate with Thermocouple Guard Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... -
Page 31: Baffle Removal And Installation
• Reinstall the baffle boards and the baffle protection channel. See Figures 4.10 and 4.11. Lower Face removed for picture clarity Figure 4.12 Fan Locations Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... - Page 32 Reinstall in the reverse order. Figure 4.14 Unplug Thermocouple Wires • Remove the (4) screws from each fan access panel and pull them forward and out. See Figure 4.15. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19...
-
Page 33: Troubleshooting
Be sure you have air available for combustion and that your firewood is dry and well seasoned. Build your fires properly and according to the instructions given in op- Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... - Page 34 Air register from furnace near fireplace? Doors opening and closing? Outside air Window closed Combustion closed? for start-up? air control Figure 5.1 Factory-built Fireplaces: Troubleshooting Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19...
-
Page 35: Troubleshooting Table
Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... - Page 36 Refer to diagnostics. Establish a good hot fire. Glass doesn’t stay clean Burning on low, wet wood Use well-seasoned wood. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19...
- Page 37 11. Fust .5A Slow IEC Glass 6. Thermocouple BLACK BLACK WHITE BLACK GREEN BLUE WHITE BLACK BLACK WHITE WHITE GREEN BLACK Figure 5.2 Circuit Board Wiring Diagram ► Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19...
-
Page 38: Reference Materials
Woodburning Fireplace Beginning Manufacturing Date: May 2019 Ending Manufacturing Date: Active PIONEER-III-ABK - Arch Door PIONEER-III-RBK - Rectangle Door 17 18 Part number list on following page. 08/19 Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19... - Page 39 SRV4182-189 Outside Air Assembly SRV4182-039 Unit Collar SRV4087-314 PIONEER-III-ABK SRV4182-064 Non-Comb Board Assembly PIONEER-III-RBK SRV4183-064 Touch Up Paint Black 812-0910 Additional service part numbers on following page. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19...
- Page 40 10 Ft 7000-811/10 29.3 Glass Retainer Qty 4 req SRV4183-240 Screw, 8-32 x 3/8 PPH BK Pkg of 40 225-0500/40 Additional service part numbers on following page. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19...
- Page 41 Screw, 8 x 1/2 PPH BK Pkg of 40 12460/40 Pkg of 25 220-0080/25 Screw, HWH MS 1/4-20 x 3/4 Washer, 3/8 SAE BK Pkg of 3 832-0990 Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19...
- Page 42 This page intentionally left blank. Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19...
-
Page 43: Contact Information
This product may be covered by one or more of the following patents: (United States) 5613487, 5647340, 5890485, 5941237, 6006743, 6019099, 6053165, 6145502, 6374822, 6484712, 6601579, 6769426, 6863064, 7077122, 7098269, 7258116, 7470729, 8147240 or other U.S. and foreign patents pending. 2000-945C Quadra-Fire • Pioneer III Owner’s Manual • 4182-900 • Rev D • 08/19...
Need help?
Do you have a question about the Pioneer-III-ABK and is the answer not in the manual?
Questions and answers