Table of Contents
Advertisement
INSTALLATION & OPERATING
WARNING!
All electric heaters have hot and arcing or sparking parts
inside. Do not use it in areas where gasoline, paint or flam-
mable liquids are or stored. Do not use where the heater
may be exposed to flammable vapors.
WARNING!
Improper installation, adjustment, alteration, service or
maintenance can cause injury or property damage. Refer to
this manual. For assistance or additional information, con-
sult a qualified installer.
INSTRUCTIONS
VILLAGE COLLECTION
QV26E
ELECTRIC FIREPLACE/INSERT
Hearth & Home Technologies Inc.
1445 North Highway, Colville, WA 99114-2124
SAVE THESE INSTRUCTIONS
Note:
Read these instructions completely before
beginning installation. Failure to follow them
could cause a heater malfunction resulting in
serious injury and/or property damage.
Do not expose the heater to the elements
(such as rain, etc.).
WARNING
This heater is tested and listed for use only with the
optional accessories listed in these instructions. Use
of optional accessories not specifically tested for this
heater could void the heater warranty and/or result in
a safety hazard.
WARNING!
Do not modify this heater. Use it only as described in
this manual. Any other use not recommended by the
manufacturer may result in fire, electric shock or per-
sonal injury and void the warranty.
CAUTION:
!
4038-827 Rev B
Advertisement
Table of Contents
Related Manuals for Quadra-Fire VILLAGE COLLECTION
Summary of Contents for Quadra-Fire VILLAGE COLLECTION
-
Page 1: Save These Instructions
INSTALLATION & OPERATING INSTRUCTIONS VILLAGE COLLECTION QV26E ELECTRIC FIREPLACE/INSERT SAVE THESE INSTRUCTIONS Note: Read these instructions completely before beginning installation. Failure to follow them could cause a heater malfunction resulting in serious injury and/or property damage. CAUTION: Do not expose the heater to the elements (such as rain, etc.). -
Page 2: Table Of Contents
19. To prevent electric shock or fire, always use a certified electrician should new circuits or outlets be required. 20. When transporting or storing the heater, keep in a dry place free from excessive vibration and store as to avoid damage. 21. SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE. 04/04 VILLAGE COLLECTION ELECTRIC FIREPLACE/INSERT 4038-827 Rev B... -
Page 3: Listing Approvals
United States, the current CSA C22.2 NO. 46 in Canada and has been listed by Underwriters Laboratories Inc. for installation as described in this manual. All components are UL or CSA safety certified. If you need assistance during installation, please contact your local dealer or the Quadra-Fire Technical Services Department at 1-800-026-4356. -
Page 4: Location And Clearances
2. Clearances Figure 1 shows all clearances that must be maintained around the heater. CAUTION: Wear gloves and safety glasses for protec- tion during installation and maintenance. Figure 1 - Heater Locations 04/04 VILLAGE COLLECTION ELECTRIC FIREPLACE/INSERT 4038-827 Rev B... -
Page 5: Framing
Provide adequate clearances around the air openings and adequate accessibility clearances for servicing and Tools: Building Supplies: proper operation. Wall-finishing materials Pliers Framing material Hammer Surround Phillips screwdriver Caulking material Tape measure Level Electric drill/bits Square Gloves 04/04 VILLAGE COLLECTION ELECTRIC FIREPLACE/INSERT 4038-827 Rev B... -
Page 6: Installation
To finish out the heater, follow the instructions found in Section “G. Finishing”. To complete heater installation, see Section “H. Final Installation”. C. Proceed to Step 3. 04/04 VILLAGE COLLECTION ELECTRIC FIREPLACE/INSERT 4038-827 Rev B... - Page 7 The warranty will be voided by, and Quadra-Fire disclaims Should the face not cover the entire ventilation grille any responsibility for, the following actions: surface, the grille should be left open.
-
Page 8: Wiring
1875 watts may be used. Note: Electrical wiring must be installed by a licensed electrician. CAUTION: Disconnect remote controls if you are absent for extended periods of time. This will prevent accidental operation of the heater. 04/04 VILLAGE COLLECTION ELECTRIC FIREPLACE/INSERT 4038-827 Rev B... - Page 9 Label all wires prior to disconnection when servicing lets. Always use ground fault protection where required controls. Wiring errors can cause improper and dangerous by electrical code. operation. Verify proper operation after servicing. Figure 3 - 110V/120V Wiring Diagram 04/04 VILLAGE COLLECTION ELECTRIC FIREPLACE/INSERT 4038-827 Rev B...
-
Page 10: Finishing
Finishing materials are normally installed be- hind the nailing flanges or up to the sides of the nailing flanges. Allow room for the front to be added and the heater to be anchored. 04/04 VILLAGE COLLECTION ELECTRIC FIREPLACE/INSERT 4038-827 Rev B... -
Page 11: Final Installation
Active only when lights are on. The thermostat allows you to adjust the desired room temperature. Set at maximum - always on below 104° F. Set at minimum - always off above 32° F. 04/04 VILLAGE COLLECTION ELECTRIC FIREPLACE/INSERT 4038-827 Rev B... -
Page 12: Maintenance Instructions
Carefully remove the burned out bulb from the light socket. Place the new bulb in the socket. See Figure 7. Figure 7 - Replacing the Bulbs Follow directions on the light bulb package for handling requirements. Reinstall the ember tray. 04/04 VILLAGE COLLECTION ELECTRIC FIREPLACE/INSERT 4038-827 Rev B... -
Page 13: Troubleshooting
2. Replace the batteries. Odor. The heater may emit a slight, harmless odor when first used. This is a normal condition caused by initial heating of the internal parts and will not occur again. 04/04 VILLAGE COLLECTION ELECTRIC FIREPLACE/INSERT 4038-827 Rev B... -
Page 14: Optional Components
PBT = Polished Brass Trim PBT26EA PBT26ER SST26EA SST = Stainless Steel Trim SST26ER Cabinets Several styles of cabinets are available for use with these heaters. See your dealer/distributor for styles and sizes. 04/04 VILLAGE COLLECTION ELECTRIC FIREPLACE/INSERT 4038-827 Rev B... - Page 15 28 in. 24 in. DF-26ERA-BK4028 Remington Avenue 40 in. 28 in. DF-26ESP-BK4028 Sun Prairie 40 in. 28 in. DF-26ERA-BK4432 Remington Avenue 44 in. 32 in. DF-26ESP-BK4432 Sun Prairie 44 in. 32 in. 04/04 VILLAGE COLLECTION ELECTRIC FIREPLACE/INSERT 4038-827 Rev B...
-
Page 16: Replacement Parts
Hearth & Home Technologies Inc. 1445 North Highway, Colville, WA 99114-2124 M. REPLACEMENT PARTS 04/04 VILLAGE COLLECTION ELECTRIC FIREPLACE/INSERT 4038-827 Rev B... - Page 17 4030-840 26 in. Insert Ember Bed 4038-816 Leveling Bolts 4038-823 Thermostat Control Assy 4038-108 Installation Manual 4038-827 QV26E Grate Assy. 4038-206 Refractory-LH-26 in. 4038-819 Refractory-RH-26 in. 4038-820 Rock, 20 oz. bag 4021-173 04/04 VILLAGE COLLECTION ELECTRIC FIREPLACE/INSERT 4038-827 Rev B...
- Page 18 Hearth & Home Technologies Inc. 1445 North Highway, Colville, WA 99114-2124 This page intentionally left blank. 04/04 VILLAGE COLLECTION ELECTRIC FIREPLACE/INSERT 4038-827 Rev B...
- Page 19 Hearth & Home Technologies Inc. 1445 North Highway, Colville, WA 99114-2124 This page intentionally left blank. 04/04 VILLAGE COLLECTION ELECTRIC FIREPLACE/INSERT 4038-827 Rev B...
-
Page 20: Warranty
How to Obtain Service. To obtain service under this warranty you must: 1. Send written notice of the claimed condition to Quadra-Fire Technical Service Department, Hearth & Home Technologies Inc., 1445 North Highway, Colville, WA 99114-2124. 2. Provide proof of purchase, model number, serial number, and manufacturing date code to HHT.
Need help?
Do you have a question about the VILLAGE COLLECTION and is the answer not in the manual?
Questions and answers