Alto-Shaam HALO HEAT ECOSMART 500-1D Installation Operation & Maintenance
  1. Manuals
  2. Brands
  3. Alto-Shaam Manuals
  4. Warming Drawer
  5. 500-1D
  6. Installation operation & maintenance

Alto-Shaam HALO HEAT ECOSMART 500-1D Installation Operation & Maintenance

Electric
Hide thumbs Also See for HALO HEAT ECOSMART 500-1D:
Table of Contents

Advertisement

Quick Links

See also: Installation Operation & Maintenance , Installation, Operation & Maintenance Manual
500-1D
500-2D
500-3D
W164 N9221 Water Street • P.O. Box 450
Menomonee Falls, Wisconsin 53052-0450 u.S.A.
262.251.3800 • 800.558.8744
PHONE:
262.251.7067 • 800.329.8744
FAX:
www.alto-shaam.com
.
.
.
p r i n t e d i n u
s
a
D r a w e r W a r m e r s
500-1DN
500-2DN
500-3DN
u.S.A. / CANADA
u.S.A. ONLY
Consult instructions
for operation and use.
e l e c t r i c
Models:
500-1D, 1DN
500-2D, 2DN
500-3D, 3DN
• InstallatIon
• operatIon
• MaIntenance
M N - 2 9 7 4 2 ( R
. 6 ) • 0 2 / 1 6
e v

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the HALO HEAT ECOSMART 500-1D and is the answer not in the manual?

Questions and answers

Related Manuals for Alto-Shaam HALO HEAT ECOSMART 500-1D

Summary of Contents for Alto-Shaam HALO HEAT ECOSMART 500-1D

  • Page 1 262.251.7067 • 800.329.8744 FAX: u.S.A. ONLY Consult instructions www.alto-shaam.com for operation and use. M N - 2 9 7 4 2 ( R . 6 ) • 0 2 / 1 6 p r i n t e d i n u...

  • Page 2: Table Of Contents

    Food Safety Delivery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Unpacking .

  • Page 3: Delivery

    Contact the Alto-Shaam Tech Team Service guarantee and relieving Alto-Shaam of all liability. Department if you have any questions concerning • DO NOT DISCARD THIS MANuAL.

  • Page 4: Safety Procedures And Precautions

    safety procedures and precautIons • This appliance is intended to cook, hold or process Knowledge of proper procedures is essential to the foods for the purpose of human consumption. No safe operation of electrically and/or gas energized other use for this appliance is authorized and is equipment.

  • Page 5: Safety Procedures And Precautions

    This may result in fire, Alto-Shaam of all liability. appliance door closed to extinguish damage to the equipment or serious injury. the fi re. If further extinguishing is •...

  • Page 6: Installation

    I t e I ns t a l l a t I o n This Alto-Shaam MInIMuM clearance appliance must ® reQuIreMents be installed in a 3"...

  • Page 7: Cutout Dimensions

    I n s t a l l a t I o n s I t e I n s t a l l a t I o n 500-1D, 500-2D, 500-3D 12-5/16" (312mm) Electrical Connection 24-5/8" (624mm) 43-3/8" (1101mm) Cord Length: 120V - 5' (1524mm) 208-240V - 8' (2438mm) 230V - 8' (2438mm)

  • Page 8: Cutout Dimensions

    I n s t a l l a t I o n s I t e I n s t a l l a t I o n 500-1DN, 500-2DN, 500-3DN 8-5/16" (211mm) Electrical Connection 16-11/16" (423mm) 53-3/4" (1364mm) Cord Length: 120V - 5' (1524mm) 208-240V - 8' (2438mm) 230V - 8' (2438mm)

  • Page 9: Electrical Specifications

    I n s t a l l a t I o n e l e c t r I c a l 1. An identification tag is permanently mounted on This section is provided for the the cabinet. assistance of qualified and trained service technicians only and is not 2.

  • Page 10: User Information

    o p e r a t I o n u s e r I n f o r M a t I o n food product tIps before InItIal use: Clean both the interior and exterior of the unit bread and rolls with a clean, damp cloth and mild soap solution.

  • Page 11: Operation

    o p e r a t I o n o p e r a t I n g I n s t r u c t I o n s 1. preheat at 200°f (93°c) for 30 MInutes 5. Check to ensure the cabinet drawer is securely before loadIng hot food.

  • Page 12: General Holding Guidelines

    o p e r a t I o n general holdIng guIdelInes Chefs, cooks and other specialized food service h o l d I n g t e M p e r a t u r e r a n g e personnel employ varied methods of cooking.

  • Page 13: Cleaning And Preventative Maintenance

    (muriatic acid) on stainless steel. extinguish a grease fi re!). Failure NEVER use wire brushes, metal to clean the appliance properly scouring pads or scrapers. invalidates the warranty and relieves Alto-Shaam of all liability. MN-29742 (Rev. 6) 02/16 • Drawer Warmers • 11...

  • Page 14: Care And Cleaning

    c a r e a n d c l e a n I n g d a n g e r w a r n I n g To prevent serious personal injury, To prevent Serious injury, death, death, or property damage: or property damage, ALWAYS DO NOT steam clean, hose down disconnect unit from power source...

  • Page 15: Food Safety

    f o o d s a f e t y Food fl avor and aroma are usually so closely related that A controlled holding environment for prepared foods is it is diffi cult, if not impossible, to separate them. There just one of the important factors involved in the prevention is also an important, inseparable relationship between of food-borne illnesses.

  • Page 16: Service

    Check main power circuit breaker to the unit and verify that the circuit breaker on the back of the unit is turned on, if applicable. Do not attempt to repair or service the unit beyond this point. Contact Alto-Shaam for the nearest authorized service agent. Repairs made by any other service agents without prior authorization by Alto-Shaam will ®...

  • Page 17: Trouble Shooting - Error Codes

    s e r v I c e t r o u b l e s h o o t I n g - e l e c t r o n I c c o n t r o l code description possible cause s Cavity air sensor reading <...

  • Page 18: Exterior Service Parts

    s e r v I c e se rv I ce v I ew - ext e rI o r 500-3D Shown ft] 1 P ar t n umb e rs a nd d r aw ing s a re s u b j e c t t o c h a n g e wi t h o u t n o t i c e . MN-29742 (Rev.
  • Page 19 s e r v I c e se rv I ce v I ew - ex t e r I o r p ar ts l I s t Item Part Description 1008272 BRACKET, SENSOR MTG. 1012473 TOP COVER IN-2003 INSULATION, FIBERGLASS, #3 DENS 1/2"...

  • Page 20: Service View - Drawer Assembly

    s e r v I c e AME SPOT se rv I ce v I ew - dr aw e r as se M bl y LLER 0 x 1-1/8" FLAT HD 500-D LDER, SHORT, S/S ER W/HANDLE WER FRONT SPOT WER, OUTER , #44, S/S THREADED, 1/4-20...

  • Page 21: Exterior Service Parts

    s e r v I c e se rv I ce v I ew - n a r r o w e x terIor 500-3DN Shown 5 [lin ft] ENTED ELIEF P ar t n umb e rs a nd d r aw ing s a re s u b j e c t t o c h a n g e wi t h o u t n o t i c e . w a r n I n g d a n g e r To prevent SERIOUS INJURY, DEATH,...
  • Page 22 s e r v I c e se rv I ce v I ew - n a r r o w e x terIor part s l Is t Item Part Description 1008272 BRACKET, SENSOR MTG. 1012779 TOP COVER IN-2003 INSULATION BK-29606 CONTROL SENSOR BLOCK...

  • Page 23: Service View - Drawer Assembly 500-Dn

    s e r v I c e se rv I ce v I ew - dr aw e r as se M bl y 500-DN Non-Vented Drawer Vented Drawer P a rt n u mb e rs a nd d r aw i n g s a re s u b j e c t to c h an g e wi t h o ut n o t i c e . Item Part Description...

  • Page 24: Electronic Service Parts

    s e r v I c e se rv I ce v I ew - el e c t r I ca l Item Part Description Item Part Description CC-34970 WARMER CONTROL WS-22297 WASHER, FLAT CR-34967 CONNECTOR-2 CONDUCTOR SC-36973 SCREW, PAN PH, METRIC, M5 SW-34769 SWITCH, ROCKER, 125-277V, 20A WS-22302 WASHER, SPLIT LOCK SP-29392...
  • Page 25 MN-29742 (Rev. 6) 02/16 • Drawer Warmers • 23...
  • Page 26 MN-29742 (Rev. 6) 02/16 • Drawer Warmers • 24...
  • Page 27 MN-29742 (Rev. 6) 02/16 • Drawer Warmers • 25...

  • Page 28: Transportation Damage And Claims

    LIMITED WARRANTY Alto-Shaam, Inc. warrants to the original purchaser only that any original part that is found to be defective in material or workmanship will, at Alto-Shaam's option, subject to provisions hereinafter stated, be replaced with a new or rebuilt part.

This manual is also suitable for:

Halo heat ecosmart 500-3dnHalo heat ecosmart 500-1dnHalo heat ecosmart 500-2dHalo heat ecosmart 500-2dnHalo heat ecosmart 500-3d

Table of Contents