Table of Contents
Advertisement
Quick Links
ULTIMATE U28 & U43 Freestanding Gas Stove
MODELS:
U28-NG2 Natural Gas
WARNING:
If the information in these instructions are not followed exact-
ly, a fire or explosion may result causing property damage,
personal injury or loss of life.
FOR YOUR SAFETY
Do not store or use gasoline or other flammable vapors and
liquids in the vicinity of this or any other appliance.
Installation and service must be performed by a qualified
installer, service agency or the gas supplier.
Tested by:
908-728
FIREPLACE PRODUCTS INTERNATIONAL LTD. 6988 Venture St., Delta, BC Canada, V4G 1H4
U28-LP2 Propane
Installer: Please complete the details on the back cover
and leave this manual with the homeowner.
Homeowner: Please keep these instructions for future reference.
Installation Manual
U43-NG3 Natural Gas
U43-LP3 Propane
FOR YOUR SAFETY
What to do if you smell gas:
Do not try to light any appliance
Do not touch any electrical switch:
do not use any phone in your build-
ing.
Immediately call your gas supplier
from a neighbour's phone. Follow
the gas supplier's instructions.
If you cannot reach your gas sup-
plier, call the fire department.
Owners &
10/13/00
Advertisement
Table of Contents
Related Manuals for Regency Fireplace Products ULTIMATE U28
Summary of Contents for Regency Fireplace Products ULTIMATE U28
- Page 1 Owners & ULTIMATE U28 & U43 Freestanding Gas Stove Installation Manual MODELS: U28-NG2 Natural Gas U28-LP2 Propane U43-NG3 Natural Gas U43-LP3 Propane FOR YOUR SAFETY WARNING: What to do if you smell gas: If the information in these instructions are not followed exact- Do not try to light any appliance...
- Page 2 To the New Owner: Congratulations! You are the owner of a state-of-the-art ULTIMATE Gas Stove by FIREPLACE PRODUCTS INTERNATIONAL LTD. The Regency Gas Series of hand crafted appliances has been designed to provide you with all the warmth and charm of a woodstove, at the flick of a switch. The models U43-NG3, U43-LP3, U28-NG2, and U28-LP2 of this series has been approved by Warnock Hersey for both safety and efficiency.
-
Page 3: Table Of Contents
TABLE OF CONTENTS Page Page Operating Instructions Safety Label Safety Label - U43-NG3 ..........4 Operating Instructions ..........15 Safety Label - U43-LP3 ..........5 Lighting Instructions.............15 Safety Label - U28-NG/LP2 ...........6 Shutdown Instructions ..........15 First Fire ..............15 Installation Convection Fan Operation...........15 Flame Height Adjustment ..........15 General Installation Information........7 Copy of Lighting Plate Instructions ......16 Installation Checklist ............8... -
Page 4: Safety Label
SAFETY LABEL This is a copy of the label that accompanies NOTE: Regency units are constantly being each ULTIMATE Freestanding Gas Stove. We improved. Check the label on the unit and if have printed a copy of the contents here for your there is a difference, the label on the unit is the review. -
Page 5: Safety Label - U43-Lp3
SAFETY LABEL Regency U28-2/U43-3 ULTIMATE Freestanding Gas Heater... -
Page 6: Safety Label - U28-Ng/Lp2
SAFETY LABEL Regency U28-2/U43-3 ULTIMATE Freestanding Gas Stove... -
Page 7: Installation
INSTALLATION BEFORE YOU START IMPORTANT: 12) Under no circumstances should this ap- pliance be modified. Parts that have to be SAVE THESE removed for servicing should be replaced Safe installation and operation of this appliance prior to operating this appliance. INSTRUCTIONS requires common sense, however, we are required by the Canadian Safety Standards... -
Page 8: Installation Checklist
INSTALLATION INSTALLATION CLEARANCES TO COMBUSTIBLES CHECKLIST U43-NG3 & U43-LP3 Clearances The clearances listed below are MINIMUM 1) Check Clearances to Combustibles, page A Side Wall to Unit 7-1/2" / 190 mm distances. Measure the clearance to both the appliance and the chimney connector. B Back Wall to Unit 6"... -
Page 9: U28: Optional Long Side Doors
INSTALLATION VENTING Outside Air Through U28: OPTIONAL Rear of Pedestal LONG SIDE DOOR This heater is a vented appliance and must be connected to a chimney/flue in accordance with INSTALLATION Remove the blanking plate from the rear of the the installation codes. pedestal cover plate and bend the two tabs out 90 degrees. -
Page 10: Vent Terminations
INSTALLATION GAS CONNECTION Vent Terminations The gas line can be rigid pipe, or to make installation easier, use a listed flexible connector if allowed by local codes. Copper may also be used if approved by local codes. The gas connection at the valve is 3/8" NPT. For minimum and maximum supply pressure see the System Data Table. -
Page 11: Log Installation
INSTALLATION LOG INSTALLATION 1) Make sure the valve is in the "OFF" position. 2) Loosen the "IN" (# 7) and/or "OUT" (# 6) WARNING: Dangerous operating conditions pressure tap(s), turning counterclockwise may occur if these logs are not positioned 5) Distribute the embers along the front burner with a 1/8"... -
Page 12: Door Installation And Door Latch
INSTALLATION FRONT DOOR TEST FOR FLUE 5) Remove the blue plastic protective coating from the glass. INSTALLATION SPILLAGE 6) Test the seal around the door by placing (packaged separately) a piece of paper between the unit and the A "spillage" test must be made before the door, close the door and try to pull the paper installed unit is left with the customer. -
Page 13: Wiring Diagram - U43
INSTALLATION WIRING DIAGRAM - U43-3 WIRING DIAGRAM - U28-2 Regency U28-2/U43-3 ULTIMATE Freestanding Gas Heater... -
Page 14: Wiring
INSTALLATION OPTIONAL WALL WIRING Thermostat Wire Table THERMOSTAT Recommended Maximum Lead Length This heater does not require a 120V A.C. supply (Two-Wire) When Using Wall for operation. In case of a power failure, the Thermostat (CP-2 System) A wall thermostat may be installed if desired. burner switch and the optional remote control/ Connect the wires as per the wiring diagrams. -
Page 15: Operating Instructions
OPERATING INSTRUCTIONS OPERATING DO NOT ATTEMPT TO CLEAN THE 3) Wait five minutes to allow gas, that may GLASS WHILE IT IS STILL HOT! have accumulated in the main burner INSTRUCTIONS compartment, to escape. If you smell gas, follow the instructions on the front of this Note: When the glass is cold and the appli- Before operating this appliance, proceed through ance is lit, it may cause condensation... -
Page 16: Copy Of Lighting Plate Instructions
OPERATING INSTRUCTIONS COPY OF THE LIGHTING PLATE INSTRUCTIONS Regency U28-2/U43-3 ULTIMATE Freestanding Gas Stove... -
Page 17: Pilot Adjustment
OPERATING INSTRUCTIONS AERATION PILOT ADJUSTMENT NORMAL OPERATING ADJUSTMENT SOUNDS OF Periodically check the pilot flames. Correct GAS APPLIANCES flame pattern has three strong blue flames: 1 The burner aeration is factory set but may need flowing around the thermopile and 1 around the adjusting due to either the local gas supply or thermocouple, and 1 flowing across the rear of altitude. -
Page 18: Maintenance
MAINTENANCE MAINTENANCE GLASS CLOTHING OR OTHER FLAMMA- INSTRUCTIONS REPLACEMENT BLE MATERIAL SHOULD NOT BE PLACED ON OR NEAR THE APPLIANCE. 1) Always shut the valve off before cleaning. Your Regency stove is supplied with high tem- For relighting, refer to lighting instructions. perature, 5 mm Neoceram ceramic glass that Keep the burner and control compartment DO NOT USE THIS APPLIANCE... -
Page 19: Panel Door
MAINTENANCE Installing Glass To remove U38 fan: put glue on the screws. Replace the door gasket, the two ends butt tight together on the bottom edge of the door. 1) Unplug or disconnect power source to stove. 1) Install both center and side glass onto extrusions as per diagram. -
Page 20: Removing Valve
MAINTENANCE To remove U28 fan: REMOVING VALVE 1) Unplug or disconnect power source to stove. If your valve requires maintenance or replace- ment, follow these instructions: 2) Remove all logs and the rear log support, then remove the 10 screws holding the NOTE: Always shut off the gas supply access panel in place, see Diagram 1. -
Page 21: Parts List - U43
PARTS LIST U43-3 MAIN ASSEMBLY Part # Description Part # Description 650-527 Side Panel Door Hinge Bracket (Left) 653-535/02 Louver Assembly 593-522 Side Panel Door Assy (Right Side) 910-199 Wire Holder Clip 650-528 Side Panel Door Hinge Bracket (Right) 590-105 Fan Cover 904-258 Side Panel Door Magnet... - Page 22 PARTS LIST U43-3 BURNER & LOG ASSEMBLIES Part # Description 910-241 Burner ON/OFF Switch (3-way) 910-190 Piezo & Nut 904-586 Knob - Fan Control 910-373 Knob - Pilot Valve Extension 910-372 Flame Adjusting Knob 908-646 Control Panel Decal 650-220 Control Panel Plate 910-330 Fan Speed Controller (120 V) 593-524/P...
- Page 23 PARTS LIST U43-3 DOOR ASSEMBLIES Part # Description 650-975 Gold Mitred Door - Complete 650-974 Black Mitred Door - Complete 650-972 Gold Wrap Door - Complete 650-970 Gold Panel Door - Complete 101) 650-920 Door Gasket Kit 105) 936-264 Ceramic Paper 106) 940-226/P Side Glass...
-
Page 24: Parts List - U28
PARTS LIST U28-2 MAIN ASSEMBLY Part # Description Part # Description 560-920 Top/Bottom Gold Louvers (set) 948-255 Door Latch c/w Hook 560-922 Top/Bottom Black Louvers (set) 910-250 Spill Switch 910-199 Wire Holder Clip 910-233 Thermodisc - Fan Auto/On/Off 910-179 Snap Bushing 650-086 Mounting Bracket - Fan Thermodisc 560-055... - Page 25 PARTS LIST U28-2 BURNER & LOG ASSEMBLY Part # Description 910-241 Burner ON/OFF Switch (3-way) 910-190 Piezo & Nut 904-586 Knob - Fan Control 910-373 Knob - Pilot Valve Extension 910-372 Flame Adjusting Knob 908-646 Control Panel Decal 650-220 Control Panel Plate 910-330 Fan Speed Control 562-524/P Valve Assembly - Natural Gas...
- Page 26 PARTS LIST U28-2 DOOR ASSEMBLIES Part # Description 560-924 Gold Mitred Door - Complete 560-926 Black Mitred Door - Complete 560-932 Gold Wrap Door - Complete 560-928 Gold Panel Door - Complete 101) 650-920 Door Gasket Kit 105) 936-264 Ceramic Paper 106) 940-236/P Side Glass...
-
Page 27: Warranty
WARRANTY Regency Fireplace Products, are designed with reliability and simplicity in mind. In addition, our internal Quality Assurance Team carefully inspects each unit thoroughly before it leaves our door. Regency Industries Ltd. is pleased to extend this limited lifetime warranty to the original purchaser of a Regency Product. - Page 28 Regency fireplace products are designed with reliability and simplicity in mind. In addition, our internal Quality Assur- ance Team carefully inspects each unit thoroughly before it leaves our door. Fireplace Products International Ltd. is pleased to extend this Limited Lifetime Warranty to the original purchaser of a Regency Product.
Need help?
Do you have a question about the ULTIMATE U28 and is the answer not in the manual?
Questions and answers