INSPECTION
Carefully unpack and inspect your SCV Rider Scrubber for shipping damage. Follow unpacking
instructions on shipping pallet. Each unit has been tested and thoroughly inspected before shipment. Any
damage is the responsibility of the delivery carrier who should be notified immediately.
ELECTRICAL
This machine is battery operated and designed to operate on 36 volts DC (6) 6-volt batteries.
BATTERIES
The recommended batteries are rated 370Ah (Minuteman P/N 956715).
We do not recommend mixing AMP hour capacities. Any alternate battery sets can be used if they equal
physical size and capacity. See page 13 for service and installation.
OPERATOR RESPONSIBILITY
Read this manual carefully before operating this machine.
The operator is responsible in taking care of the daily maintenance and check ups of the machine to keep
it in good working condition. The operator must inform the service mechanic or supervisor when the
scheduled maintenance intervals are required as stated in the MAINTENANCE section of this manual.
Before starting familiarize yourself with the machine and its controls (see "Machine Overview, Front",
"Machine Overview, Rear", "Operator Compartment", "Control Console" diagrams).
MACHINE COMPONENTS
FRONT
A
Front drive wheel
B
Side squeegee
C
Headlights
Accelerator pedal
D
E
Tilt-wheel lever
F
Steering wheel
G
Operator's seat
H
Recovery tank lid
I
Recovery tank
J
Control console
K
Directional switch
L
Safety latch
M
Battery compartment
N
Solution tank
O
Electrical panel
P
Parking brake
Q
Rear Squeegee
Rear wheel
R
S
Scrub deck
1