Procedure For Ordering Parts; Recommended Spare Parts List - Sullair LS-10 25HP Operators Manual And Parts Lists

8.1 PROCEDURE FOR ORDERING PARTS

Parts should be ordered from the nearest Sullair Representative or the Representative from whom the com-
pressor was purchased. If for any reason parts cannot be obtained in this manner, contact the factory directly
at the addresses, phone or fax numbers listed below.
When ordering parts always indicate the Serial Number of the compressor. This can be obtained from the Bill
of Lading for the compressor or from the Serial Number Plate located on the compressor.
SULLAIR ASIA, LTD.
Sullair Road, No. 1
Chiwan, Shekou
Shenzhen, Guangdong PRV.
PRC POST CODE 518068
Telephone: 755-- 6851686
Fax: 755-- 6853473

8.2 RECOMMENDED SPARE PARTS LIST

DESCRIPTION
element, compressor fluid filter 02250096---783
element, heavy duty air filter 02250107---327 (25---30HP/ 19---22KW)
element, heavy duty air filter 040595 (40HP/ 30 KW)
element, primary replacement for separator 250034---113
kit, repair for air inlet valve 02250088---348
kit, repair springs for air inlet valve 02250088---348
kit, repair for minimum pressure/check valve 02250097---609
kit, repair cap for minimum pressure/check valve 02250097---609
kit, repair o---ring for minimum pressure/check valve 02250097---609
kit, repair piston for minimum pressure/check valve 02250097---609
kit, repair thermal valve 02250096---738 (170˚F)
kit, repair thermal valve 02250103---509 (190˚F)
kit, repair for pressure regulator 250017---280
kit, repair for blowdown valve 250025---655
kit, repair for solenoid valve 250038---674 (<= 140 psi/ 9.7 bar)
kit, replacement for solenoid valve coil 250038---674 (<= 140 psi/ 9.7 bar)
kit, repair for solenoid valve 250038---675 (>140 psi/ 9.7 bar)
kit, replacement for solenoid valve coil 250038---675 (>140 psi/ 9.7 bar)
kit, repair inlet valve 02250088---348
kit, repair for v---type strainer 241771
kit, repair for shaft seal
element, replacement for combination separator/trap 02250078---841
kit, repair automatic drain for combination separator/trap 02250078---841
manual, Sequencing & Protocol (I)
fluid, SRF 1/4000 (5 gallons)
lubricant, Sullube 32 (std.) (5 gallons)
lubricant, 24 KT (5 gallons)
(I) This document is required to program your personal computer to communicate with the Supervisor II
panel.
(II) For proper amount of fluid fill, please consult Lubrication Guide in Section 3, Specifications.
PLEASE NOTE: WHEN ORDERING PARTS, ALWAYS INDICATE SERIAL NUMBER OF COMPRESSOR
ILLUSTRATIONS AND PARTS LIST
SULLAIR CORPORATION
Subsidiary of Sundstrand Corporation
3700 East Michigan Boulevard
Michigan City, Indiana 46360 U.S.A.
Telephone: 1-- 219-- 879-- 5451
Fax: (219) 874-- 1273
Fax: (219) 874-- 1835 (Parts)
Fax: (219) 874-- 1288 (Service)
SULLAIR EUROPE, S.A.
Zone Des Granges BP 82
42602 Montbrison Cedex, France
Telephone: 33-- 477968470
Fax: 33 -- 477968499
KIT NUMBER
250025-- 525
250034-- 114
250019-- 451
250029-- 315
250026-- 758
02250046-- 397
02250048-- 362
02250051-- 338
250025-- 621
02250103-- 562
250019-- 453
250031-- 772
250038-- 673
250031-- 738
02250055-- 939
250038-- 730
250019-- 451
001836-- 007
02250081-- 108
02250087-- 422
02250057-- 696
250019-- 662
250022-- 669
046850-- 001
Section 8
QTY
1
043334 1
040596 1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
241772 1
1
1
1
1
(II)
(II)
(II)
45