Download
Share
Print this page
  1. Manuals
  2. Brands
  3. Prince Castle Manuals
  4. Toaster
  5. 340-TCE
  6. Operation manual

Prince Castle 340-TCE Operation Manual

Universal rapid toaster
Hide thumbs

Advertisement

Quick Links

Download this manual
Operation
Manual
Main Product Section
Club Section
Start Button
Control Panel
On/Off Switch
LIMITED WARRANTY
This product is warranted to be free from defects in material and/
or workmanship for a period of two (2) years from date of original
installation, not to exceed 30 months from date of shipment from
our factory. Any part or component which proves to be faulty in
material and/or workmanship within the warranty period will be
replaced or repaired (at the option of Prince Castle, Inc.) without
cost to the customer for parts or labor.
This warranty is subject to the following exceptions/conditions:
• Use of any non-genuine Prince Castle parts voids this
warranty and all work must be performed by an authorized
Prince Castle Service Agent.
• All labor shall be performed during regular work hours.
Overtime premium will not be covered.
• Travel charges are limited to 100 miles (200 kilometers) round
trip, 2 hours travel time, one trip per repair.
• Damage caused by carelessness, neglect, and/or abuse (e.g.,
using wrong current, dropping, tampering with or altering
electrical components, or improper cleaning) is not covered.
• Equipment damaged in shipment, by fire, flood or an act of
God is not covered.
• Damage to non-stick coated surfaces is not covered by this
warranty.
Only use URT Cleaning Tool with a sponge pad to clean the platens. Do NOT use anything abrasive because it will scratch the
platens, which could cause bun sticking. Do not use abrasive materials such as scrapers, steel wool, etc. to clean the Buffered
Bun Landing Zone or exterior of the unit, as damage to the surface could occur.
Do NOT use any unapproved agents or cleaning solutions inside or on the surfaces of the toaster unit.
340-506-EN
Product Identification
Buffed Bun Landing Zone
(BBLZ)
355 East Kehoe Blvd. • Carol Stream, IL 60188 USA
Telephone: 630-462-8800 • Toll Free: 1-800-PCASTLE
Fax: 630-462-1460 • www.princecastle.com
PRODUCT
Button
INFORMATION
Button
PRINCE CASTLE Logo Button
TABLE OF CONTENTS
Product Identification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Important . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Loading Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation Tips . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adjustments/Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Programming . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
CAUTION
Universal Rapid Toaster
340-TCE
LED Display
Left and Right
LIGHT/DARK Buttons
UP and DOWN
Scroll Buttons
SANITATION
Printed in USA 3/06 © 2006
1
2
2
2
4
6
7
8
9
9

Advertisement

loading

Related Manuals for Prince Castle 340-TCE

Summary of Contents for Prince Castle 340-TCE

  • Page 1 Installation ........replaced or repaired (at the option of Prince Castle, Inc.) without cost to the customer for parts or labor.
  • Page 2 Universal Rapid Toaster 340-TCE Safety Information Important Prince Castle reserves the right to change specifications WARNING and product design without notice. Such revisions do not entitle the buyer to corresponding changes, improvements, Indicates information important to the proper operation of additions or replacements for previously purchased the unit.
  • Page 3 Universal Rapid Toaster 340-TCE Installation (continued) A. Push the BBLZ into position. The BBLZ is in the A. On the “rear” chamber, push the bun chute into the correct position when the mounting holes on the toaster from the back toward the front, aligning the...
  • Page 4 Universal Rapid Toaster 340-TCE Installation (continued) To connect toaster units, push the rear toaster unit CAUTION behind the front toaster unit, tilting the rear unit back and raising the bun chute of the rear unit slightly so All electrical connections must be in accordance with that it slides over the BBLZ of the front unit.
  • Page 5 Universal Rapid Toaster 340-TCE Operation (continued) NOTE: To cancel any operation in progress and release LUNCH LOADING the bread product inside a chamber, press and hold the A. The toaster can be easily loaded from either side of the START button for 1.5 seconds, then release it to cycle prep table.
  • Page 6 Universal Rapid Toaster 340-TCE Loading Diagram Bagel Cut Side-Out Radiant Heater Radiant Heater Cut Side-Out Muffin Cut Side-Out Radiant Heater Radiant Heater Cut Side-Out Crown Club Cut Side-In Platen Heel Club Cut Side-In Printed in USA 3/06 © 2006 340-506-EN...
  • Page 7 Bun Organization The Prince Castle URT is naturally organized so that you can toast “in lanes.” Use the two slots closest to the START button to toast Regular buns and the two slots furthest for Quarters. Then when buffering buns, these buns are already in their “buffering locations.”...
  • Page 8 Use with caution. To reset all settings to manufacturer’s defaults, turn the unit OFF. Then, turn the unit back ON and press and hold the PRINCE CASTLE Logo button together with the UP and DOWN buttons (all simultaneously) for 3 seconds.
  • Page 9 Each bread product must be adjusted independently on each toasting chamber. To enter the Program Mode, press and hold the A. Using the UP and DOWN scroll buttons, scroll PRINCE CASTLE Logo button for 6 seconds. through the main menu to find the bread product you want to change.
  • Page 10 Universal Rapid Toaster 340-TCE Cleaning (continued) On the toaster, press the PRODUCT button on the A. Wipe the BBLZ with McD All Purpose Super Control Panel until the display reads “OFF”. Concentrate (APSC), sanitize with McD Kayquat Sanitizer and wipe clean with sanitized cloth.

  • Page 11: Troubleshooting

    When LED is on, 3. Turn unit ON and immediately press and hold the voltage across the output PRINCE CASTLE Logo button, the terminals should be INFORMATION button, and the PRODUCT minimal. When LED is button.
  • Page 12 Universal Rapid Toaster 340-TCE Troubleshooting (continued) SYMPTOM POSSIBLE CAUSE CHECK REMEDY Bagels or muffins are Toaster settings are 1. Reduce toast temperature of both radiant Change both toast time and too dark or burnt. incorrect. heaters. (Temperature is decreased by...
  • Page 13 When LED is on, 3. Turn unit ON and immediately press and hold the voltage across the output PRINCE CASTLE Logo button, the terminals should be INFORMATION button, and the PRODUCT minimal. When LED is button.
  • Page 14 Universal Rapid Toaster 340-TCE Troubleshooting (continued) SYMPTOM POSSIBLE CAUSE CHECK REMEDY Buns are not toasted Main PCB is failing. Measure the voltage output at the relay connection at Replace main PCB. or product is not dark the main PCB. When the unit is not calling for heat, enough (continued).
  • Page 15 ½". (Verify the gap setting on the HEEL side.) 4. Reconnect power to the toaster. (Do NOT reconnect motor to PCB.) 5. Press the PRINCE CASTLE Logo button on the correct control panel. Hold the logo button until the display reads “Program Mode”.
  • Page 16 Universal Rapid Toaster 340-TCE Exploded View and Parts List Printed in USA 3/06 © 2006 340-506-EN...

  • Page 17: Wiring Diagram

    Universal Rapid Toaster 340-TCE Wiring Diagram 340-506-EN Printed in USA 3/06 © 2006...
  • Page 18 355 East Kehoe Blvd. • Carol Stream, IL 60188 USA Telephone: 630-462-8800 • Fax: 630-462-1460 Printed in 3/06 Toll Free: 1-800-PCASTLE Prince Castle Inc. www.princecastle.com...