Prince Castle CTS-W Operation Manual

Prince Castle CTS-W Operation Manual

Contact toaster - single-sided

Advertisement

Original Instructions
Operation Manual
LIMITED WARRANTY
This product is warranted to be free from defects in material and/or
workmanship for a period of one (1) year from date of original
installation, not to exceed 18 months from date of shipment from
our factory. Any part or component which proves to be faulty in
material and/or workmanship within the warranty period will be
replaced or repaired (at the option of Prince Castle LLC) without
cost to the customer for parts or labor.
This warranty is subject to the following exceptions/conditions:
• Use of any non-genuine Prince Castle parts voids this
warranty and all work must be performed by an authorized
Prince Castle Service Agent.
• All labor shall be performed during regular work hours.
Overtime premium will not be covered.
• Travel charges are limited to 100 miles (200 kilometers) round
trip, 2 hours travel time, one trip per repair.
• Damage caused by carelessness, neglect, and/or abuse (e.g.,
using wrong current, dropping, tampering with or altering
electrical components, or improper cleaning) is not covered.
• Equipment damaged in shipment, by fire, flood or an act of
God is not covered.
• Damage to non-stick coated surfaces is not covered by this
warranty.
355 East Kehoe Blvd. • Carol Stream, IL 60188 USA
Telephone: 630-462-8800 • Toll Free: 1-800-PCASTLE
299-500revD-EN
Fax: 630-462-1460 • www.princecastle.com
Contact Toaster - Single-Sided
CTS-WCE/CTS-MCE/CTS-WSCE
Contact Toaster - Single-Sided
This appliance is designed for toasting bread products in a commercial
kitchen. Customer-adjustable features include:
• Crush Adjustment
• Set Temperature
• Toast Time (Speed of Conveyor)
• Scale (°F or C°)
The conveyor belt may be wire, metal (Stainless Steel) or silicone.
Silicone belt is consumable to be replaced 2-6 months
dependent on usage and is not covered under warranty.
WS - Silicone
Conveyor

TABLE OF CONTENTS

Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electrical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Setting Adjustments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Daily Planned Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . .
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Uninstalling and Installing the Silicone Belt . . . . . . . . . . . . . . 10
Service Kits . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Revision Log . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
TM
CTS-W/CTS-M/CTS-WS
W - Wire
M - Metal
Conveyor
Conveyor
Printed in USA 03/17 © 2017
2
2
2
4
6
7
9

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the CTS-W and is the answer not in the manual?

Questions and answers

Summary of Contents for Prince Castle CTS-W

  • Page 1: Table Of Contents

    Operation ........replaced or repaired (at the option of Prince Castle LLC) without cost to the customer for parts or labor.
  • Page 2: Safety Information

    Contact Toaster – Single-Sided CTS-W/CTS-M/CTS-WS/CTS-WCE/CTS-MCE/CTS-WSCE Safety Information IMPORTANT: Prince Castle reserves the right to change specifications and product design without notice. Such revisions do not entitle the buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment. WARNING Indicates information important to the proper operation of the unit.
  • Page 3 Contact Toaster – Single-Sided CTS-W/CTS-M/CTS-WS/CTS-WCE/CTS-MCE/CTS-WSCE Installation (continued) Clean the bun infeed, conveyor and CTS. Put on Reinstall the bun infeed. neoprene gloves. Dampen a clean cloth with lukewarm soap and water. Wipe the conveyor, rotating it as you clean to reach its entire surface. Wipe the infeed and outside of the entire CTS.
  • Page 4: Operation

    Contact Toaster – Single-Sided CTS-W/CTS-M/CTS-WS/CTS-WCE/CTS-MCE/CTS-WSCE Operation Turn unit on. Turn the On/Off switch located WARNING on the lower right to the BURN/ELECTRICAL SHOCK HAZARD! Platen area On position. The is HOT and can cause severe burns or severe version information will shock.
  • Page 5 Contact Toaster – Single-Sided CTS-W/CTS-M/CTS-WS/CTS-WCE/CTS-MCE/CTS-WSCE Operation (continued) Make any desired adjustments. Use the instructions in Setting Adjustments to make changes to the crush adjustment, the set temperature, the temperature scale and/or the time it takes to toast. Begin continuous feeding. Feed product into top of CTS, sending the correct product parts down the left and right sides of the unit.
  • Page 6: Setting Adjustments

    Contact Toaster – Single-Sided CTS-W/CTS-M/CTS-WS/CTS-WCE/CTS-MCE/CTS-WSCE Setting Adjustments Change crush adjustment. Because the platen has Change the set temperature, temperature scale separate segments for the left (“Heel” side) and right and/or time that it takes to toast. (“Crown” side - usually thicker), they are adjusted separately, each with its own crush adjustment knob.
  • Page 7: Daily Planned Maintenance

    Contact Toaster – Single-Sided CTS-W/CTS-M/CTS-WS/CTS-WCE/CTS-MCE/CTS-WSCE Daily Planned Maintenance Remove bun WARNING infeed by lifting from toaster. BURN/ELECTRICAL SHOCK HAZARD! Platen area is HOT and can cause severe burns or severe shock. Keep hands and objects out of the toaster unit! Failure...
  • Page 8 Contact Toaster – Single-Sided CTS-W/CTS-M/CTS-WS/CTS-WCE/CTS-MCE/CTS-WSCE Daily Planned Maintenance (continued) Clean the release sheet. Dampen a clean cloth Clean outside of the CTS. Dampen a clean cloth with with lukewarm soap and water. Wipe down both lukewarm soap and water. Wipe down the outside of sides of the release sheet, making sure all built-up the entire CTS.
  • Page 9: Troubleshooting

    Contact Toaster – Single-Sided CTS-W/CTS-M/CTS-WS/CTS-WCE/CTS-MCE/CTS-WSCE Troubleshooting WARNING BURN/ELECTRICAL SHOCK HAZARD! Platen is HOT and can cause severe burns or severe shock. Keep hands and objects out of the toaster unit! Failure to exercise caution may result in serious injury! Turn the unit off, unplug it and let it cool down completely before touching or working on internal apparatus. The plug removed from the outlet shall remain clearly visible to the operator during the maintenance procedure.
  • Page 10: Uninstalling And Installing The Silicone Belt

    Contact Toaster – Single-Sided CTS-W/CTS-M/CTS-WS/CTS-WCE/CTS-MCE/CTS-WSCE Uninstalling and Installing the Silicone Belt IMPORANT: Belt is consumable that must be replaced every 2-6 months, dependent on usage and wear. Uninstall the silicon belt. Ensure the CTS is off and D. While holding the free end with one hand, rotate not hot to the touch.
  • Page 11: Service Kits

    Contact Toaster – Single-Sided CTS-W/CTS-M/CTS-WS/CTS-WCE/CTS-MCE/CTS-WSCE Service Kits 299-030S 299-029S 299-017S 527-468S Control Board Kit Display Board Kit Overlay Kit Temperature Probe Kit 299-072S 299-060S 299-046S 299-070S Triac Kit Motor Kit Gears Kit Bearing Kit 299-020S 299-041S 299-058S 78-233S Wire Conveyor Assy. Kit...
  • Page 12 Contact Toaster – Single-Sided CTS-W/CTS-M/CTS-WS/CTS-WCE/CTS-MCE/CTS-WSCE Service Kits Consumables 299-061S 299-063S Release Sheet Silicon Conveyor Belt 299-500revC-EN Printed in USA 03/17 © 2017...
  • Page 13: Accessories

    Contact Toaster – Single-Sided CTS-W/CTS-M/CTS-WS/CTS-WCE/CTS-MCE/CTS-WSCE Accessories Butter Wheel Hanging Points 511-140 Butter Wheel Printed in USA 03/17 © 2017 299-500revC-EN...
  • Page 14: Wiring Diagram

    Contact Toaster – Single-Sided CTS-W/CTS-M/CTS-WS/CTS-WCE/CTS-MCE/CTS-WSCE Wiring Diagram 299-500revC-EN Printed in USA 03/17 © 2017...
  • Page 15: Revision Log

    Contact Toaster – Single-Sided CTS-W/CTS-M/CTS-WS/CTS-WCE/CTS-MCE/CTS-WSCE Revision Log PAGE DESCRIPTION DATE VERSION RESPONSIBLE PERSON The Silicon Conveyor Belt part kit number changed from 299-062S to Alexander Malevanets 1/10/2019 299-063S. 299-010S/022S 115/240V Platen Assys, and 299-011S/012S 115/240V Alexander Malevanets 1/23/2019 Platen service kits added.

This manual is also suitable for:

Cts-mCts-wsCts-wceCts-mceCts-wsce

Table of Contents