Table of Contents
Advertisement
Quick Links
Operation
Operation
Manual
Manual
LIMITED WARRANTY
This product is warranted to be free from defects in material and/or
workmanship for a period of 1 year from date of original installation, not
to exceed 18 months from the date of manufacture.
Any component which proves to be faulty in material and/or workmanship
will be replaced or repaired (at the option of Prince Castle, Inc.) without cost
to the customer for parts and labor. This warranty covers on-location service
(i.e. trip charges and/or mileage). Travel mileage is limited to 100 miles
(200 Kilometers) round trip (one trip warranty) from an authorized service
agency or its sub-service agency.
This warranty is subject to the following exceptions/conditions:
• Use of any non-genuine Prince Castle parts voids this warranty.
• All labor to be performed during regular work hours. Overtime
premium (the incremental amount) will be charged to the customer.
• Damage caused by carelessness, neglect and/or abuse (e.g., dropping,
tampering or altering parts, equipment damaged in shipment, by fire,
flood or an act of God) is not covered under this warranty.
• All problems due to operation at voltages other than that specified on
equipment nameplates are not covered by this warranty. Conversion
to correct voltage is the customer's responsibility.
• This equipment must be serviced by Prince Castle Authorized Service
Agency or a Prince Castle Service Technician during the warranty period.
537-528revC-EN
355 East Kehoe Blvd. • Carol Stream, IL 60188
Phone: 630-462-8800 • Toll Free: 1-800-PCASTLE
Fax: 630-462-1460 • www.princecastle.com
TABLE OF CONTENTS
Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Electrical Specifications . . . . . . . . . . . . . . . . . . . . . . . . .2
Product Identification . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Daily Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Programming . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Parts List and Exploded View . . . . . . . . . . . . . . . . . . .8-9
Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
T
OASTER
T
OASTER
TX-230EBKCE
TX-230EBKCE
Printed in USA 2/06 © 2006
Advertisement
Table of Contents
Related Manuals for Prince Castle TX-230EBKCE
Summary of Contents for Prince Castle TX-230EBKCE
-
Page 1: Table Of Contents
18 months from the date of manufacture. Any component which proves to be faulty in material and/or workmanship will be replaced or repaired (at the option of Prince Castle, Inc.) without cost to the customer for parts and labor. This warranty covers on-location service (i.e. -
Page 2: Safety Information
Sales Department at 800-722-7853 or 1-630-462-8800 to arrange for a replacement unit. Prince Castle reserves the right to change specifications and product design without notice. Such revisions do not entitle the buyer to corresponding changes, improvements, additions or replacements 537-528revC-EN Electrical Specifications Model No. -
Page 3: Operation
Press the On/Off Button to turn the unit off. A = Thinnest Cut F = Thickest Cut TOASTER TX-230EBKCE Bun Chute If the heater is above 450°F, the display will alternately show “ C C O O O O L L ” and “ O O F F F F ”, and the con- veyor belt will continue to run approximately 45 minutes. -
Page 4: Daily Cleaning
Lower Retaining Bar Loosen the thumbscrews and remove the side panel. Thumbscrews To release tension on the conveyor belt, press in and down on the roller. TOASTER TX-230EBKCE Remove release sheet Printed in USA 2/06 © 2006... - Page 5 When reassembling release sheet, be sure to install upper and lower retaining bars in the correct end. Release Sheet Upper Retaining Bar TOASTER TX-230EBKCE Release Sheet Lower Retaining Bar Printed in USA 2/06 © 2006...
-
Page 6: Control Panel
Use the UP or DOWN Arrow Buttons to adjust to the desired setpoint. R D Y R D Y TOASTER TX-230EBKCE 5 4 0 R D Y 5 4 0 Press and release the SET Button to save the new setpoint and return to the operation mode. -
Page 7: Troubleshooting
R R D D Y Y to L L O O . If the dis- play remains at L L O O for 30 minutes, , contact an authorized Prince Castle Service Agent. 537-528revC-EN Troubleshooting Possible Cause No power to unit. -
Page 8: Parts List And Exploded View
65-058 537-295S 86-355S 537-735S 537-348S 66-034 72-373S 537-729S 65-048-14 537-388S 537-400 TOASTER TX-230EBKCE Description RH Upright Platen Insulation Heater Housing Heater Housing Plate Rear Panel RH Cover Bun Thickness Overlay Hi-Temperature Switch PC Board & Overlay Assy. RH Cam Shaft... -
Page 9: Parts List And Exploded View
Part No. 537-411 537-315 537-317S 79-055S 81-017S 86-272S 69-011S 76-640 TOASTER TX-230EBKCE Description Upper Roller Upper Shaft Upper Bearing (Package of 2) Washer (Package of 2) Spring (Package of 2) Cotter Pin (Package of 2) Rivet (Package of 4) Screw... -
Page 10: Wiring Diagram
DISTRIBUTION TERMINAL BLOCK OPTIONAL FUSE BLOCK SEE CONNECTION DETAIL FOR USAGE CONTROL BOARD 240V 200V MOTOR TOASTER TX-230EBKCE POWER C NO RELAY POWER TERMINAL BLOCK POWER CORD 3A FUSE BLOCK CONNECT WHITE WIRE CONNECTION DETAIL TO PROPER MOTOR USED ONLY ON VOLTAGE TAB TX-208 &...
Need help?
Do you have a question about the TX-230EBKCE and is the answer not in the manual?
Questions and answers