Safety Instructions; Intended Purpose; General; Explosive Gases - Mastervolt CombiMaster 230V Series User And Installation Manual

1 SAFETY INSTRUCTIONS

IMPORTANT SAFETY INSTRUCTIONS
SAVE THESE INSTRUCTIONS
Read the entire manual before using the CombiMaster. Keep this manual in a secure place.
1.1

Intended purpose

Use the CombiMaster only:
•
for the charging of lead acid and Lithium-Ion batteries and the supply of loads attached to these batteries, in permanent
systems;
•
for the conversion of a DC voltage from a battery to an AC voltage;
•
connected to a dedicated double pole circuit breaker and earth leakage switch;
•
with a fuse, protecting the wiring between CombiMaster and battery;
•
in a technical correct condition;
•
in a well-ventilated room, protected against rain, moisture, dust and condensation;
•
observing the instructions in the user manual.
1.2

General

1. The appliance is not to be used by children or persons with reduced physical, sensory or mental capabilities, or lack of
experience and knowledge, unless they have been given supervision or instruction.
To reduce the risk of electric shock – Do not expose the CombiMaster to rain, snow, spray, moisture, excessive pollution
2.
and condensing circumstances. To reduce risk of fire hazard, do not cover or obstruct the ventilation openings. Do not
install the CombiMaster in a non-ventilated room, as overheating may result.
3. Use of an accessory or spare part not recommended or sold by Mastervolt may result in a risk of fire, electric shock, or
personal injury.
4. The CombiMaster is designed to be permanently connected to an AC and DC electrical system. Installation of, and work
on the CombiMaster, may be carried out only by qualified and trained personnel, consistent with the locally applicable
standards and regulations.
5. Make sure that all wiring is properly installed, in good electrical condition, and correctly sized to match the AC ampere
rating of the CombiMaster. Check the wiring on a regular base, at least once a year. Do not use the CombiMaster when
the wiring is undersized or damaged.
6. Do not operate the CombiMaster if it has received a sharp blow, been dropped, or otherwise damaged in any way.
Contact your supplier or Mastervolt.
7. Except for the connection compartment (see chapter 4), the CombiMaster may not be opened or disassembled. There
are no serviceable parts inside the case of the CombiMaster. Take it to a qualified serviceman when service or repair is
required. Incorrect reassembly may result in a risk of electric shock or fire.
8. To reduce risk of electric shock, disconnect the CombiMaster from both AC and DC electrical system before attempting
any maintenance or cleaning. Turning off controls will not reduce this risk. Be sure that third parties cannot reverse the
measures taken.
9. Short circuiting or reversing polarity will lead to serious damage to batteries, CombiMaster, wiring as well as accessories.
Fuses cannot prevent damage caused by reversed polarity and the warranty will be void.
10. In case of fire, you must use the fire extinguisher which is appropriate for electrical equipment.
1.3

Explosive gases

–
1.
WARNING RISK OF EXPLOSIVE GASES
EXPLOSIVE GASES DURING NORMAL OPERATION
C M ,
OMBI ASTER YOU READ THIS MANUAL AND FOLLOW THE INSTRUCTIONS EXACTLY
2. To reduce the risk of battery explosion, follow these instructions and those published by the battery manufacturer and
manufacturer of any equipment you intend to use in the vicinity of the battery. Review cautionary marking on these
products and on engine.
1.4

Personal precautions

1. Consider having someone close by to come to your aid when you work near a lead-acid battery.
2. Wear eye and clothing protection. Avoid touching eyes while working near battery.
3. NEVER smoke or allow a spark or flame in vicinity of battery or engine.
4. Do not wear watches, bracelets, necklaces or other metal objects when working on batteries.
CombiMaster 230V Series – User and Installation Manual
.
WORKING IN THE VICINITY OF A LEAD
. ,
FOR THIS REASON
-
ACID BATTERY IS DANGEROUS
IT IS OF UTMOST IMPORTANCE THAT EACH TIME BEFORE USING THE
.
3
.
BATTERIES GENERATE