Tire Service Kit Usage Precautions - RAM Commercial PROMASTER Cargo Van 2019 User Manual

Using The Mode Select Knob And Hoses
Your Tire Service Kit is equipped with the
following symbols to indicate the air or seal-
ant mode.
Selecting Air Mode
Turn the Mode Select Knob (2) to this posi-
tion for air pump operation only. Use the
Black Air Pump Hose (5) when selecting this
mode.
Selecting Sealant Mode
Turn the Mode Select Knob (2) to this posi-
tion to inject the Tire Service Kit Sealant and
to inflate the tire. Use the Sealant Hose (clear
hose) (3) when selecting this mode.
Using The Power Button
Push and release the Power Button (1) once
to turn on the Tire Service Kit. Push and
release the Power Button (1) again to turn Off
the Tire Service Kit.
Using The Deflation Button
Push the Deflation Button (9) to reduce the
air pressure in the tire if it becomes over-
inflated.
Tire Service Kit Usage
Precautions
• Replace the Tire Service Kit Sealant Bottle
(4) and Sealant Hose (3) prior to the expi-
ration date (printed at the upper right hand
corner on the bottle label) to assure opti-
mum operation of the system. Refer to
"Sealing A Tire With Tire Service Kit" sec-
tion (F) "Sealant Bottle And Hose Replace-
ment".
• The Sealant Bottle (4) and Sealant Hose (3)
are a one tire application use and need to
be replaced after each use. Always replace
these components immediately at your
original equipment vehicle dealer.
• When the Tire Service Kit sealant is in a
liquid form, clean water and a damp cloth
will remove the material from the vehicle or
tire and wheel components. Once the seal-
ant dries, it can easily be peeled off and
properly discarded.
• For optimum performance, make sure the
valve stem on the wheel is free of debris
before connecting the Tire Service Kit.
• You can use the Tire Service Kit air pump to
inflate bicycle tires. The kit also comes with
two needles, located in the Accessory Stor-
age Compartment (on the bottom of the air
pump) for inflating sport balls, rafts, or
similar inflatable items. However, use only
the Air Pump Hose (5) and make sure the
Mode Select Knob (2) is in the Air Mode
when inflating such items to avoid injecting
sealant into them. The Tire Service Kit
Sealant is only intended to seal punctures
less than 1/4 inch (6 mm) diameter in the
tread of your tire.
• Do not lift or carry the Tire Service Kit by the
hoses.
WARNING!
• Do not attempt to seal a tire on the side of
the vehicle closest to traffic. Pull far
enough off the road to avoid the danger of
being hit when using the Tire Service Kit.
• Do not use Tire Service Kit or drive the
vehicle under the following circum-
stances:
– If the puncture in the tire tread is
approximately 1/4 inch (6 mm) or
larger.
91