Generac Power Systems Protector Series Owner's Manual page 4

Table of Contents
Section 5: Maintenance
Component Locations .......................................27
Access Panels ....................................................29
Removal .................................................................... 29
Installation ................................................................. 29
Service Maintenance Intervals .........................29
Remove From Service .......................................30
30 Hour Break-In ................................................31
Daily Maintenance (If Running Continuously) ....31
Schedule A Maintenance ..................................31
Preliminary Instructions ............................................. 31
Check Fuel Level and Fill .......................................... 31
Drain Fuel Filter and Check Fuel Lines/Hoses ......... 32
Check Coolant Level and Hoses ............................... 32
Check Radiator for Clogging ..................................... 32
Check Lubricating Oil Level ...................................... 33
Check Battery Condition/Fluid Level ......................... 33
Battery Replacement ................................................ 34
Check and Adjust V-Belt ........................................... 34
Adjust V-Belt Tension ............................................... 35
Replace Air Filter Element-2.5L Engine ........36
Replace Air Filter Element-2.2L Engine ........36
Lubricate Governor Rod Linkage
(2.5L Engine) ......................................................37
Final Instructions ....................................................... 37
Schedule B Maintenance ..................................37
Replace Lubricating Oil and Oil Filter ....................... 37
Drain Fuel Filter and Check Fuel Lines/Hoses ......... 38
Prime Fuel System .................................................... 38
Drain/Flush Coolant System ..................................... 38
Final Instructions ....................................................... 39
Schedule C Maintenance ..................................40
Return To Service ..............................................40
iv
Section 6: Troubleshooting
Engine Troubleshooting ................................... 41
Controller Troubleshooting .............................. 42
Removal From Service During
Utility Outages.................................................... 43
Storage ............................................................... 43
Prepare For Storage ................................................. 43
Return From Storage ................................................ 44
Attention After Submersion ............................. 45
Attention After Fuel Spillage ............................ 45
Contaminated Fuel Disposal ............................ 45
Owner's Manual for Stationary Generators