Cleaning; Watering; Charging - Taylor-Dunn TC-30 Operator's Manual

Cleaning

WARNING
1) Refer to battery warnings at the start of this chapter.
2) Park the vehicle in an authorized service area and turn the engine OFF.
3) Place the shift lever in Park or Neutral if Park is not available.
4) Set the parking brake.
Note: If the terminals show signs of excessive corrosion then refer cleaning to an authorized
technician.
5. Dry dirt can be readily blown off with low-pressure air or brushed off.
6. Wetness or wet dirt on the battery indicates battery acid. Using a nonmetallic brush with
flexible bristles, wash the battery off with a strong solution of baking soda and hot water (one
pound of soda to a gallon of water). Continue until all fizzing stops, which indicates that the
acid has been neutralized. Then rinse thoroughly with clear water. DO NOT get any of the
solution into the battery cells.

Watering

Non-maintenance free batteries only.
WARNING
1) Refer to battery warnings at the start of this chapter.
2) Park the vehicle in an authorized service area and turn the engine OFF.
3) Place the shift lever in Park or Neutral if Park is not available.
4) Set the parking brake.
CAUTION
Do not overfill the battery. Over filling the battery may cause the batteries to boil over
and result in chemical burns and/or property damage.
Note: If the terminals show signs of excessive corrosion
then refer cleaning to an authorized technician.
5. Clean the battery. Refer to Cleaning section for
information on cleaning the battery.
6. Check the electrolyte level in all battery cells.
If low, fill to the correct level with distilled water
using part number 77-201-00 battery filler. Never
add additional battery electrolyte to the batteries.
7. Remove the blocks from the wheels and test drive.

Charging

A dead battery may be a result of a faulty battery or charging system.
If you have a dead battery then refer charging and testing to an authorized technician.
Page 52 Tiger TC-3060 Operator Manual
MT-030-60-E