Page 1
HL 2.30 NT HL 2.40 NT Date automotive lift: 04/2013 Operating instruction: 22.04.2013 Valid from SN:350974 Modified: 08-2013 Operating instruction and documentation Serial-no.:......Händleradresse / Telefon Made in Germany Otto Nußbaum GmbH & Co.KG // Korker Straße 24//D-77694 Kehl-Bodersweier Tel: +49(0)7853/8990 Fax: +49(0)7853/8787...
3. Technical Information ......................11 3.1 Technical Data ........................ 11 3.2 Safety devices......................... 12 3.3 Data sheet HL 2.30 NT ....................13 3.4 Data sheet HL 2.40 NT ....................16 3.5 Foundation plan ......................16 3.6 Hydraulic plan ......................... 20 3.7 Electrical diagram ......................
Dangers when operating with the lift: The Nussbaum-Lifts are designed and built according to technical standard and the approved regulations for technical security. Yet, danger for body and life of the operator may turn up when using the lift inexpertly.
Page 4
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT Organising requirements The instructions for use are constantly to be kept at the place of operation being at hand at any time. In addition to the instructions for use rules pertaining to other regulations i.e. accident prevention and environmental rules are to be observed and directed.
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT Fill out, undersign and copy this sheet and send the original to the lift manufacturer. The copy remains in the Manual. Otto Nußbaum GmbH & Co. KG Korker Straße 24...
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT Record of handing over The automotive lift with the serial number:..........was installed on:..........at the firm:..........at:..............the safety was checked and the lift was started. The persons below were introduced after the installation of the automotive lift. The introduction was carried out from an erector of the lift-manufacturer or from a franchised dealer (competent person).
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT 1.Introduction The document ”Operating Instruction and Documentation” contains important information about installation, operation and maintenance of the lift. To furnish proof of the installation of the automotive lift the form ”Record of Installation” must be signed and returned to the manufacturer.
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT 2. Master document of the automotive lift 2.1 Lift–manufacturer Otto Nußbaum GmbH & Co.KG Korker Strasse 24 D-77694 Kehl-Bodersweier 2.2 Application The automotive lift is a lifting device for lifting and repairing vehicles with a lifting weight of ...(see the list) with a maximum load distribution of (2:3**) (1:3***) in or against the drive in direction.
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT 2.3 Changes at the construction Changes at the construction, expert checking, resumption of work (date, kind of change, signature of the expert) ................................................................................................name, address of the expert ............
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT 3. Technical Information 3.1 Technical Data Capacity: HL 2.30 NT = 3000kg HL 2.40 NT = 4000kg Load per lifting arm: It is forbidden to raise the load only with one carrying arm.
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT 3.2 Safety devices 1. Pressure relief valve Overprint-safety of the hydraulic system 2. Holding valve safety device against unintentional lowering 3. Lockable main switch safety device against unauthorised operation 4. Two independent cylinder hydraulic system (master and slave system) Safety device against unintentional lowering 5.
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT 4. Safety regulations When using automotive lifts the German safety regulation BGG945: Examine of automotive-lifts; BGR500 Using automotive-lifts; (VBG14) must be observe adhered to. Especially the following regulations are very important: •...
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT 5. Operating instructions The Safety Regulations must be observed during working with the automotive lift. Read the safety regulations in chapter 4 carefully before working with the lift! 5.1 Positioning the vehicle •...
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT Pic 3: Press the rear lever to unlock the pads. • Examine the locking device of the arms. They must be locked before raising the vehicle with the lift. •...
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT 5.3 Synchronism of the automotive lift • An unequal run is excluded by proper Operation and with the two independent hydraulic systems. • Raise the lift without vehicle into the top limit position. Operate the operating lever approx.
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT 6. Troubleshooting If the lift does not work properly, the reason for this might be quite simple. Please check the lift for the potential reasons mentioned on the following pages. If the cause of trouble cannot be found, please call the technical service of the dealer.
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT 6.1 Emergency lowering It is possible to lower the vehicle into the lowest position with a simply operation. The emergency lowering must only carried out by persons which are instructed to using the lift.
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT 7.1 Maintenance plan Before beginning any maintenance work isolate the power supply. Secure the main switch (lock it). Secure the danger area around the automotive lift and secure the lift...
Page 34
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT MINI-MAX lifting arm Clean the Mini-Max in regularly interval with air pressure. That is a reason-prerequisite for a trouble- free function. In case of a strong contamination, a monthly cleaning is to be enforced.
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT Check the condition and function of the electrical components for damage. plugs min. once in a year Operating lever with the switch Daily Check always the condition of the cables during the installation..
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT 7.3 Examine of the stability of the automotive lift • Examine the dowels with a torque key as described by the dowel manufacturer. Observe the declaration of the dowel manufacturer.
Page 37
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT In case of doubt a test boring has to be performed and a dowel is to set in. Afterwards the dowel is tighten with a torque which is described of the dowel manufacturer.
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT to the next pages (Dowels without tiles, floor pavement). If the ground is covered with floor tiles, the dowels have to be chosen according to the next pages. (Dowels with tiles, floor pavement).
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT 8.2 Installation the lifting arms • Position the standard arms at the lifting carriage. Lubricate the bolts and put the bolts into the provided position. After that, secure it with the safety rings.
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT • Loosen and remove the dowels. • Transport the lift to the new installation place. • Install the lift in accordance with chapter 8 “ Installation and Initiation” Use new dowels, the used dowels can not be used anymore.
Page 41
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT Betonqualität min C20/25 normal bewehrt Quality of concrete Normal armouring Änderungen vorbehalten! subject to alterations! sous réserve des modifications! HL 2.30 NT Hilti-Injektionsdübel HL 2.40 NT Betonboden / concrete floor ohne Bodenbelag / without floor pavement (tiles) Dübel...
Page 42
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT Markierung der Verankerungstiefe Änderungen vorbehalten! subject to alterations! sous réserve des modifications! fischer-Dübel HL 2.30 NT HL 2.40 NT Dübel typ of dowel FH 15/50 B FH 18 x 100/100 B FH 24/100 B Bestellnr.
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT First security check before installation Fill out and leave in this manual Serial-number:__________________________ defect veri- kind of check right missing fication remark ---------------------------------------------------------------------------------------------------------------------------------------- Condition Type plate.................... Short operation instruction.........
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT Regular security check and maintenance Fill out and leave in this manual Serial-number:__________________________ defect veri- kind of check right missing fication remark ---------------------------------------------------------------------------------------------------------------------------------------- Condition Type plate.................... Short operation instruction.........
Page 45
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT Regular security check and maintenance Fill out and leave in this manual Serial-number:__________________________ defect veri- kind of check right missing fication remark ---------------------------------------------------------------------------------------------------------------------------------------- Condition Type plate.................... Short operation instruction.........
Page 46
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT Regular security check and maintenance Fill out and leave in this manual Serial-number:__________________________ defect veri- kind of check right missing fication remark ---------------------------------------------------------------------------------------------------------------------------------------- Condition Type plate.................... Short operation instruction.........
Page 47
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT Regular security check and maintenance Fill out and leave in this manual Serial-number:__________________________ defect veri- kind of check right missing fication remark ---------------------------------------------------------------------------------------------------------------------------------------- Condition Type plate.................... Short operation instruction.........
Page 48
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT Regular security check and maintenance Fill out and leave in this manual Serial-number:__________________________ defect veri- kind of check right missing fication remark ---------------------------------------------------------------------------------------------------------------------------------------- Condition Type plate.................... Short operation instruction.........
Page 49
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT Regular security check and maintenance Fill out and leave in this manual Serial-number:__________________________ defect veri- kind of check right missing fication remark ---------------------------------------------------------------------------------------------------------------------------------------- Condition Type plate.................... Short operation instruction.........
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT Extraordinary security check Fill out and leave in this manual Serial-number:__________________________ defect veri- kind of check right missing fication remark ---------------------------------------------------------------------------------------------------------------------------------------- Condition Type plate.................... Short operation instruction................... Sticker capacity at the lift…………………..
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT Optional Riser pipes Verlängerung extension Verlängerung extension Die optionalen Steigrohrverlängerungen werden in einem Karton angeliefert. The Riser pipes where delivered in a box. Les rehausses sont livrées en carton. Mitgelieferte Teile bereitlegen Prepair the different pieces Repérer les differentes Pièce.
Page 52
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT Steigrohrverlängerung auf das vorhandene Steig- rohr aufsetzen. Offene Seite zeigt nach innen Place the riser Pipes on the top of the column. The opening shows to the inner side. Placer la rehausse sur le pont, partie ouverte vers l’intérieur...
Page 53
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT Vorhandene Hydraulikleitungen entfernen. Farbmarkierung nicht entfernen. Change the position of the Hydraulic pieces Do not remove the color marking. Modifier la position des raccords hydrauliques Ne retirez pas la marque d'encre.
Page 54
Operating instruction and documentation HL 2.30 NT/ HL 2.40 NT Blau an K1 an der Bediensäule anschließen Install the Blue on K1 at the master column Bleu vérin K1cote commande Abdeckblech auf Länge zuschneiden und montieren. Cut the cover plate and fix it.
Need help?
Do you have a question about the HL 2.30 NT and is the answer not in the manual?
Questions and answers