Warning Lamp; Checkpoints After Starting The Engine - Kubota u25 Operator's Manual

BWarning Lamp
The warning lamp is used to indicate broken wire, short-
circuit, fuel shortage and other problems.
A Do not just look at the meter, but also carry out the
inspection and correction accordingly.
A The warning lamp starts flashing in red if a serious
problem occurs. If the system gets in warning signal,
the warning lamp starts flashing in yellow.
A Warnings and errors are displayed and an alarm
buzzer beeps.
A Let your KUBOTA dealer inform you of details
concerning care and maintenance.

(1) Warning lamp

(2) Error code
C Overheat warning
If the water temperature has risen too high, the water
temperature warning lamp lights up and the following
error code (E:015) gets displayed.
(1) Water temperature warning lamp
(2) Error code
OPERATION OF THE ENGINE
With the error code displayed, take the procedure below.
1. Bring the machine to a stop on a safe place. (Get the
engine unloaded.)
2. Do not yet stop the engine, but allow it to run idle
unloaded for 5 minutes or so. Then stop the engine.
3. Keep yourself away enough from the machine for
another 10 minutes or while the engine is emitting
steam.
4. Make sure there is no risk of getting burned. Then
remove the cause
"TROUBLESHOOTING". Finally get the engine
restarted.
BCheckpoints after Starting the Engine
After starting the engine, but before starting operation,
check the following points:
1. Put the throttle lever in position "LOW" and let the
engine idle for approx. five minutes. This allows the
engine lubricant to warm up and penetrate every part
of the engine.
Note:
A This idling is usually called "Warm-up".
2. Once the engine has warmed up, check:
A the warning lamp "Engine oil pressure" has gone
out.
A the warning lamp "Battery charge" goes out when
engine speed is increased.
A the color of the exhaust is normal and no abnormal
noises or vibrations are heard or felt.
A no fluid is leaking from pipes or hoses.
C Should any following conditions occur, stop the
engine immediately.
A The engine rpm's increases or decreases suddenly.
A Sudden abnormal noises are heard.
A Exhaust is black.
A Warning lamp for engine oil lights up during operation.
A In these cases, the excavator must be checked and
serviced by your local the KUBOTA dealer.
of overheat, referring
17
to