Yamaha SXV70ERG Supplementary Service Manual page 12

Item
Check operation and fluid leakage.
Brake and parking brake Adjust free play and/or replace pads if necessary.
Replace brake fluid.
Check for slight free play.
Disc brake
Lubricate shaft with specified grease as required.
Check oil level.
Drive chain oil Drive chain oil
Replace.
Check deflection.
Drive chain
Adjust if necessary.
Check for wear and damage.
Skis and ski runners Skis and ski runners
Replace if necessary.
Check operation.
Steering system Steering system
Adjust toe-out if necessary.
Check operation.
Lights
Replace bulbs if necessary.
Check fluid level.
Add only distilled water if necessary.
Battery Battery
Check specific gravity and breather hose opera-
(SXV70ER)
tion.
Charge/correct if necessary.
Check engagement and shift speed.
Adjust if necessary.
Inspect sheaves for wear/damage.
Inspect weights/rollers and bushings for wearfor
Primary and secondary
primary.
clutches
Inspect ramp shoes/bushings for wear-for second-
ary.
Replace if necessary.
Lubricate with specified grease.
Steering column bearing Lubricate with specified grease.
Ski and front suspension Lubricate with specified grease.
Suspension component Lubricate with specified grease.
Lubricate with specified grease.
Parking brake cable end g
and lever end/throttle
Check cable damage.
cable end
Replace if necessary.
Shroud latches Make sure that the shroud latches are hooked.
Check tightness.
Fittings and fasteners
Repair if necessary.
Tool kit and recom-
Check for proper placement.
mended equipment
NOTE:
Brake fluid replacement:
1. When disassembling the master cylinder or caliper cylinder, replace the brake fluid. Normally check
the brake fluid level and add the fluid as required.
2. On the inner parts of the master cylinder and caliper cylinder, replace the oil seals every two years.
3. Replace the brake hose every four years, or if cracked or damaged.
PERIODIC MAINTENANCE TABLE
Remarks
g g
–6–
INSP
ADJ
Initial
Preoperation 1 month
check or 800 km
(Daily) (500 mi)
(40 hr)
F
See NOTE.
F
Initial at 500 km (300 mi) and every 800 km
(500 mi) thereafter.
F
F
F
F
Whenever operating elevation is changed.
F
F
F
Every
Seasonally or
3,200 km
(2,000 mi)
(160 hr)
F
Every 1,600 km
(1,000 mi)
F
2
F
F
F
F
F
F
F
F
F
F
F