Club Car CARRYALL I 1997 Owner's Manual page 20

VEHICLE FEATURE IDENTIFICATION
HOT MANIFOLD
AND MUFFLER
(ON ENGINE)
! WARNING
Negative frame ground. Do not contact positive
battery post or cable to frame as this can cause
battery explosion, electrical shocks, and burns.
FRAME GROUND
WARNING
(ON FRAME)
14
CARRYALL VI GASOLINE
WARNING
!
HOT manifold and muffler
can cause severe burns.
(+)
Periodic Service Schedule
®
ClubCar
Service Regular Interval
1. Check Oil Level Monthly
Checking Engine Oil Level
2. Oil and Filter Change First - 100 Hours
*Additional - Annually or 200 Hours
3. Check Condition and Clean One Year Under Normal Use
Air Filter Element Six Months Under Dusty Conditions
1
3
4. Change Air Filter * Two Years or 300 Hours
5. Check Tire Pressure Monthly (See Manual)
6. Replace Fuel Filters * Two Years or 300 Hours
7. Check / Fill Drive Unit * One Year or 150 Hours
Full
Level 8. Check / Fill Transmission * One Year or 150 Hours
Safe
Level
! WARNING
2
Low
Level
Governor is factory adjusted for
12 - 14 mph max. Do not tamper with
adjustment. To do so:
SAE 30 above 32°F (0ºC) or
1) will void the warranty; 2) may result in
SAE 5 W20 below 32°F (0°C)
damage to the engine or components;
Classification SE, SF, SG or Higher
3) could result in severe personal injury.
*Whichever comes first
PERIODIC SERVICE
SCHEDULE
(ON INTAKE BOX)
GASOLINE TANK
DANGER LABEL
(ON FRAME)
• Gasoline – extremely flammable.
!
• Keep heat, sparks and open flame away from fuel
tank and fuel lines.
DANGER
• Do not add fuel while engine is running or hot.
• Service by trained personnel.
MOVING PARTS
WARNING LABEL
(ON FRAME)
WARNING
!
MOVING PARTS