Club Car CARRYALL I 1997 Owner's Manual page 11

VEHICLE FEATURE IDENTIFICATION
HOT MANIFOLD WARNING
!
AND MUFFLER
HOT manifold and muffler
(ON ENGINE)
can cause severe burns.
FORWARD - REVERSE
FORWARD - REVERSE
LEVER
LEVER
!
Negative frame ground. Do not contact positive
battery post or cable to frame as this can cause
battery explosion, electrical shocks, and burns.
FRAME GROUND
WARNING
(ON FRAME)
(ON BODY UNDER SEAT)
DANGER
WARNING
(+)
EXPLOSIVE
GASES
CAN CAUSE
BLINDNESS OR INJURY
KEEP OUT OF THE REACH OF CHILDREN – DO NOT TIP – KEEP VENT CAPS TIGHT AND LEVEL
(ON BODY UNDER SEAT)
GASOLINE TANK
DANGER LABEL
• Gasoline – extremely flammable.
!
• Keep heat, sparks and open flame away from fuel
tank and fuel lines.
• Do not add fuel while engine is running or hot.
• Service by trained personnel.
CHOKE
DANGER / POISON
!
FLUSH EYES
IMMEDIATELY
SULFURIC
NO
WITH WATER
ACID
SHIELD
• SPARKS
CAN CAUSE GET
EYES
• FLAMES MEDICAL
BLINDNESS OR
• SMOKING HELP
SEVERE BURNS
FAST
BATTERY DANGER
LABEL
MOVING PARTS
WARNING LABEL
(ON FRAME BESIDE FENDER)
WARNING
!
MOVING PARTS
®
ClubCar
Service Regular Interval
1. Check Oil Level Monthly
Checking Engine Oil Level
2. Oil and Filter Change First - 100 Hours
*Additional - Annually or 200 Hours
3. Check Condition and Clean One Year Under Normal Use
Air Filter Element Six Months Under Dusty Conditions
1
3
4. Change Air Filter * Two Years or 300 Hours
5. Check Tire Pressure Monthly (See Manual)
6. Replace Fuel Filters * Two Years or 300 Hours
7. Check / Fill Drive Unit * One Year or 150 Hours
Full 8. Check / Fill Transmission * One Year or 150 Hours
Level
Safe
! WARNING
Level
2
Low
Level
Governor is factory adjusted for
12 - 14 mph max. Do not tamper with
adjustment. To do so:
SAE 30 above 32°F (0ºC) or
1) will void the warranty; 2) may result in
SAE 5 W20 below 32°F (0°C)
damage to the engine or components;
Classification SE, SF, SG or Higher
3) could result in severe personal injury.
*Whichever comes first
PERIODIC SERVICE
SCHEDULE
(ON INTAKE BOX)
5