Battery Removal - KSR Moto T58 - ZION 125 Repair Manual

ELECTRICAL SYSTEM/ BATTERY
BATTERY GENERAL INFORMATION
Take care that after each maintenance the lid is closed correct to
avoid that water or others penetrate.
NOTE
1. The battery can be charged and discharged over again. If the
battery is unused after discharge the service life will shorten
and the performance will degrade. Generally the performance
of the battery used for 2 or 3 years will degrade. Such battery
(capacity declined) may restore it´s voltage after charging but
the voltage will drop off rapidly when loaded.
2. Surcharge of battery: Generally surcharge can be observed
from the battery proper. If the battery is shorted inside no volt-
age can be tested at the terminal of the battery or the voltage
is very low.
3. Invalidation of the regulator: The battery will have too high
voltage which may reduce its service life.
4. Long rest of the battery will result in self discharge and the
electric capacity will reduce. Therefore it must be charged at
least every 3 months.
5. Inspect the charging system in accordance with the order stip-
ulated in the fault diagnosis table.
6. If there is electric current passes through an electrical unit do
not disassemble the connector otherwise over-tension will oc-
cur which can damage the electronic parts inside the voltage
regulator. The main switch must be turned "off" before any
operation.
7. Maintenance free battery does not need inspection, replenish
of electrolyte solution or distilled water.
8. Inspect the entire power load.
situations.
10. When ever charging the battery it must be removed from the
motorcycle before charging.
11.
teries.
12. A voltage meter (3) must be used when inspecting the charg-
ing conditions. Connecting the positive pole of charger and
the positive pole of battery. Connecting the negative pole of
charger and the negative pole of battery.

BATTERY REMOVAL

1.
2. Dismantle the clamping bar components of battery cell.
3. Disassemble the negative wire and then the positive wire.
4. Take out the battery.
WARNING
!
• When ever you remove the battery from the vehicle, discon-
• When you install the battery to the vehicle, connect the plus
and the cables.
100
-
3
+
-