Be sure to keep the carton, packing inserts, packing lists and carrier’s receipt until the inspector has verified your claim. MINUTEMAN’s liability ceases when the carrier picks up the shipment. However, our customer service staff will be happy to furnish any information needed in connection with the claim and will attempt to expedite a resolution.
SAFETY INSTRUCTIONS FAILURE TO COMPLY WITH THE FOLLOWING WARNINGS AND INSTRUCTIONS WILL VOID THE WARRANTY. WARNING! The machine was designed for use on carpet cleaning applications as per instructions and recommendations written in this manual. Any deviation from its proper use or purpose and the consequential damage that may occur is the sole responsibility of the end user.
Page 6
All repairs must be done by an authorized MINUTEMAN repair station. Do not use replacement parts other than original MINUTEMAN parts. Do not allow your spray stream to remain in one fixed location as surface damage may occur. Check that all spray nozzles are securely fastened. Loose nozzles could be ejected from equipment at high speeds.
GROUNDING GROUNDING INSTRUCTIONS: This piece of equipment must be grounded. Should an electrical malfunction occur, grounding provides a path of least resistance for electrical current- reducing the risk of electric shock. This piece of equipment is furnished with a cord that has a grounding conductor and grounding plug. The grounded plug must only be plugged into an appropriate outlet that is properly installed and grounded in accordance with all local codes and ordinances.
MAINTENANCE MAINTENANCE: This R100 has been engineered and built to require minimum maintenance. But like any machine, it does require some care to keep it in optimum working condition. Careful attention to these maintenance instructions will give you maximum operating performance and life expectancy of the machine. CAUTION: Disconnect the power cord from the outlet before doing any clean up or maintenance on the machine Keep the machine clean.
CORD STORAGE: While not in use, storage can be accomplished by winding cord around handle assy. Cord should be completely unwound during operation. CORD SAFETY Do not leave appliance when plugged in. Unplug from outlet when not in use and before servicing Do not use with damaged cord or plug.
MACHINE OVERVIEW Handle- Used to maneuver and position Recovery/vacuum hose inlet barb- the R100C. connect your recovery vacuum Contains switch box (For switchbox, see hose to this barb #10) Solution line Q.D.- Pressurized Recovery tank and lid- Tank collects connection for solu- tion line recovered waste water.
CLEANING CARPET CLEANING CARPET Using a dedicated dry vacuum, pre-vacuum the space to be cleaned to remove as much dirt as possible. Do not use the extractor to dry vacuum as it does not have a dry filter. Pre-spray the carpet Pour clean water or solution into the solution tank.
CLEANING UPHOLSTERY CLEANING UPHOLSTERY: Cleaning upholstery with success requires a good knowledge of the type of fabric to be worked on. Look for the cleaning instruction label sewn on the underside of the furniture for the recommended method of cleaning the fabric. If it calls for dry cleaning, do not attempt to clean with the wet extraction method.
UPPER ASSEMBLY BOM BILL OF MATERIAL ITEM PART NO. QTY DESCRIPTION ITEM PART NO. QTY DESCRIPTION F11787-MM SOLUTION TANK B00177-1 TERMINAL LUG, FEMALE, QD, 0.25 X 0.032 F11788-MM RECOVERY TANK B00185- WIRE,14 GA WHITE, UL1015, 10 E11124 GASKET, RECOVERY TANK C02315 LOCKWASHER, #10 INT.
TROUBLESHOOTING ELECTRICAL SYSTEM PROBLEM SOLUTION NO ELECTRICAL POWER 1. Defective power cord. 2. House or building circuit breaker tripped POWER IS INTERMITTENT TO ONE OR ALL MO- 1. Faulty electrical cable. TORS 2. Defective switches. 3. Loose terminal or discolored terminal connections. VACUUM SYSTEM PROBLEM SOLUTION...
Minuteman International, Inc. warrants to the original purchaser/user that the product is free from defects in workmanship and materials under normal use. Minuteman will, at its option, repair or replace without charge, parts that fail under normal use and service when operated and maintained in accordance with the applicable operation and instruction manuals.
Page 21
Model Parts Labor Poly Travel** Cord Electric Group 5yrs 12yrs 90 days Battery Auto Scrubbers (incl. on board 5yrs 3yrs 12yrs 90 days charger) Battery and Manual Sweepers 3yrs 3yrs 12yrs 90 days Exceptions……. Model Parts Labor Poly Travel** Port A Scrub, all models (incl. on board 6months 12yrs 90 days...
Page 22
“Excellence Meets Clean” Minuteman is a Full Line Manufacturer of Sweepers and Scrubbers, for Industrial Facilities. 14N845 U.S. Route 20, Pingree Grove, IL 60140 USA Phone (800) 323-9420 - www.minutemanintl.com A Member of the Hako Group 988755 Rev A 06/17...