Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Minuteman R500H
Summary of Contents for Minuteman R500H
- Page 1 Parts and Instruction Manual R500H Rush Carpet Extractor...
-
Page 2: Technical Specifications
Rush 500 12 gallon 11 gallon Dual 2-stage 500 psi sure 150” Polyethylene ¼” aluminum 10” non-marking 4” locking 35”H x 31”L x 18”W 19”W amps 2000 W 25’ Stainless Steel Parts and Instruction Manual - R500H Rush Carpet Extractor... -
Page 3: Table Of Contents
CLEANING UPHOLSTERY ......................... 15 UPPER ASSEMBLY ..........................16 UPPER ASSEMBLY BOM ......................... 17 LOWER ASSEMBLY ........................... 18 LOWER ASSEMBLY BOM ........................ 19 WIRING ............................... 20 TROUBLESHOOTING ........................21 WARRANTY ............................22 Parts and Instruction Manual - R500H Rush Carpet Extractor... -
Page 4: Inspection
MINUTEMAN’s liability ceases when the carrier picks up the shipment. However, our customer service staff will be happy to furnish any information needed in connection with the claim and will attempt to expedite a resolution. -
Page 5: Safety Instructions
This equipment is not designed to handle or use combustible/volatile substances such as gasoline or kerosene, in, on, or near the machine. The use of such materials will cause extreme hazardous condition. Do not expose machine to freezing temperatures. Parts and Instruction Manual - R500H Rush Carpet Extractor Page 5... - Page 6 All repairs must be done by an authorized MINUTEMAN repair station. Do not use replacement parts other than original MINUTEMAN parts. Do not allow your spray stream to remain in one fixed location as surface damage may occur. Check that all spray nozzles are securely fastened. Loose nozzles could be ejected from equipment at high speeds.
-
Page 7: Grounding
Extension cords connected to this machine should be 12 gauge, three-wire cords with three-prong plugs and outlets. DO NOT use extension cords more than 25 feet (7.6 m) long Figure 1 Parts and Instruction Manual - R500H Rush Carpet Extractor Page 7... -
Page 8: Maintenance
1. Check and clean solution filter 2. Check for obstructions in vacuum pathway Quarterly: 1. Check pump, plumbing and fittings for lea 2. Check power cords and hoses for tears Parts and Instruction Manual - R500H Rush Carpet Extractor Page 8... -
Page 9: Cord Storage
Do not unplug by pulling cord. To unplug, grasp the plug, not the cord. Do not handle plug or appliance with wet hands. This equipment should be stored indoors and not exposed to rain. Parts and Instruction Manual - R500H Rush Carpet Extractor Page 9... -
Page 10: Machine Overview
14. Switch box- one switch marked “VACUUM” and 10” wheels. one switch marked “PUMP”. 5. Recovery/vacuum hose inlet barb- connect your 15. Heater recovery vacuum hose to this barb. Parts and Instruction Manual - R500H Rush Carpet Extractor Page 10... - Page 11 8. RESET ACCESS POINT- Allows access to the R500H. breaker switch in the event the unit has been run dry. Parts and Instruction Manual - R500H Rush Carpet Extractor Page 11...
-
Page 12: Accessory Heater
3. Connect your heater’s inlet hose (#1 on page ) to the machine’s outlet quick disconnect (#6 on page 4. Connect your 25ft solution hose to #5 on page Parts and Instruction Manual - R500H Rush Carpet Extractor Page 12... - Page 13 5. Your R500H has two cords- One for the Extractor and one for the heater. Each cord requires a separate 15AMP circuit. Connect your 50FT power cord to the twist lock pigtail on the heater (#4 on page 11). Plug another 50ft power cord to the twist lock pigtail on the back of the machine (#6 on page 10) 6.
-
Page 14: Cleaning Carpet
10. When the job is completed, turn the switches off, including the heater, and disconnect the vacuum and solution hoses from the carpet tool and the machine. Drain the recovery tank through the drain valve as before. Parts and Instruction Manual - R500H Rush Carpet Extractor Page 14... -
Page 15: Cleaning Upholstery
8. On heavily soiled areas like arm rests, pre-treat with a recommended pre-spray and /or hold the upholstery tool a few inches above the fabric and press lever to spray on the solution before making a pass. Parts and Instruction Manual - R500H Rush Carpet Extractor Page 15... -
Page 16: Upper Assembly
UPPER ASSEMBLY 11 12 13 14 15 *NOT R500H SHOWN* FRONT UPPER MINUTEMAN 8-24-16 DECAL PART#H13699 Parts and Instruction Manual - R500H Rush Carpet Extractor Page 16... -
Page 17: Upper Assembly Bom
SCREW, 8-32 X 3/8 E010453 GASKET, SWITCH BRACKET D13153 STAINLESS STEEL LANYARD B00177-1 TERMINAL LUG, FEMALE, QD, K00666 90 ELBOW, SCHD 40, 1.5" .25 X .032 B00185-30 WIRE,14 GA WHITE, UL1015, 5 Parts and Instruction Manual - R500H Rush Carpet Extractor Page 17... -
Page 18: Lower Assembly
LOWER ASSEMBLY R500H BASE 8-25-16 20 21 22 67 68 64 65 66 Parts and Instruction Manual - R500H Rush Carpet Extractor Page 18... -
Page 19: Lower Assembly Bom
TEE, .25 FP, BRASS E11169 GASKET, VAC MOTOR, GALAXY A12960 .25X.25 HEX NIPPLE A12964 1/4" X 1/4" HEX A00104 QD, 1/4 M X 1-4 FP, BRASS H13951 PRIMING LABEL Parts and Instruction Manual - R500H Rush Carpet Extractor Page 19... -
Page 20: Wiring
WIRING Parts and Instruction Manual - R500H Rush Carpet Extractor Page 20... -
Page 21: Troubleshooting
4. Worn pump bearing (excessive noise). 5. Punctured pump diaphragm. 6. Defective rectifier or motor. 7. Worn nozzles. ERRATIC PRESSURE 1. Pump check valves defective or dirty 2. Lost prime. Parts and Instruction Manual - R500H Rush Carpet Extractor Page 21... -
Page 22: Warranty
WARRANTY... - Page 24 “Excellence Meets Clean” Minuteman is a Full Line Manufacturer of Sweepers and Scrubbers, for Industrial Facilities. 14N845 U.S. Route 20, Pingree Grove, IL 60140 USA Phone (800) 323-9420 - www.minutemanintl.com A Member of the Hako Group 988757 Rev * 08/16...