TABLE OF CONTENTS RECEIVING YOUR EQUIPMENT................... WARNINGS AND SAFETY....................ELECTRICAL INFORMATION..................GROUNDING INSTRUCTIONS..................MAINTENANCE........................ CORD STORAGE AND SAFETY..................MACHINE LAYOUT......................HEATER LAYOUT......................HOW TO USE AN ACCESSORY HEATER..............CLEANING CARPET......................CLEANING UPHOLSTERY....................TROUBLESHOOTING..................... WIRING..........................BREAKDOWN UPPER..................... 12, 13 BREAKDOWN LOWER....................14, 15 WARRANTY INFO......................
When your package is delivered, check the carton carefully for signs LOWING WARNINGS AND INSTRUCTIONS of rough handling. If your R100H is damaged, notify the WILL VOID THE WARRANTY. carrier immediately and request an inspection. Be sure to keep the carton, packing inserts, packing lists and carri- WARNING! er’s receipt until the inspector has verified your claim.
Extension cords connected to this machine should be • The accessory heater was designed for use on R100H 12 gauge, three-wire cords with three-prong plugs and extractors for carpet, floor and upholstery extraction outlets. DO NOT use extension cords more than 25 feet applications.
• Adhere to the appropriate mix ratios for all chemicals corners. Do not run this R100H over cord. Keep cord • For optimal performance, it is suggested that the away from heated surfaces.
1. Handle- Used to maneuver and position the R100H. 6. Solution line Q.D.- Pressurized connection for solu- Contains switch box (for switchbox, see #12). tion line. 2. Recovery tank and lid- Tank collects recovered waste 7. Male twist lock pigtail- Connects to 50ft power cord.
6. HANDLE- Used to hold and transport the heater nects to machine’s outlet. 7. MOUNTING FEET- Used to engage the mount- 2. POWER SWITCH. ing brackets on an R100H extractor and secure the 3. LAMP- Indicates when heat element is on and work- heater. ing.
5. Connect the power cord on the heater to the female twistlock plug located on the rear of the R100H. 1. Fill the solution tank of your R100H extractor with sufficient water or solution for the task at hand. Do not use water over 130 degrees F.
CLEANING CARPET CLEANING UPHOLSTERY: 1. Using a dedicated dry vacuum, pre-vacuum the space Cleaning upholstery with success requires a good knowl- to be cleaned to remove as much dirt as possible. Do edge of the type of fabric to be worked on. Look for the not use the extractor to dry vacuum as it does not cleaning instruction label sewn on the underside of the have a dry filter.
ELECTRICAL SYSTEM PROBLEM SOLUTION NO ELECTRICAL POWER 1. Defective power cord. 2. House or building circuit breaker tripped POWER IS INTERMITTENT TO ONE OR ALL MO- 1. Faulty electrical cable. TORS 2. Defective switches. 3. Loose terminal or discolored terminal connections. VACUUM SYSTEM PROBLEM SOLUTION...
Page 13
R100H UPPER 4-27-16 ITEM PART NUMBER DESCRIPTION QTY. F11787-MM Solution Tank F11788-MM Recovery Tank F11791-MM Lid, Solution Tank E11124 Gasket, Recovery Tank 12904A Stand Pipe Assembly K11965 Elbow, 180 Deg. Float Ball K00672 Pvc Pipe, 1.5 X 12 in, Sch 40 Wht...
20 21 *NOT SHOWN* FEMALE TWIST LOCK RECEPTACLE PART#B11304 *FOR RECEPTACLE FASTENING SCREWS, USE #39 R100H BASE 4-27-16...
Page 15
R100H BASE 4-27-16 ITEM PART NUMBER DESCRIPTION QTY. C00297 Screw,#8 X .25 in, Pan Head J11863 Hose, 3 in J00639 Screw Clamp, 1.63 - 2.43in. J00618 Vacuum Hose, 2in Grey, Wire, 22 in lg F11178-BLK Intercooler, Black C00273 Locknut, 1-4 X 20, Nylon, SS C00233 Washer, Flat, .25 in...
Page 20
“Excellence Meets Clean” Minuteman International · 14N845 U.S. Route 20 · Pingree Grove, Illinois 60140 USA Phone 630- 627-6900 · Fax 630- 627-1130 E-Mail: tech@minutemanintl.com Website www.minutemanintl.com A Member of the Hako Group...